PACCAR IS RECALLING CERTAIN MODEL YEAR 2007-2008 KENWORTH AND PETERBILT VEHICLES MANUFACTURED FROM FEBRUARY

Dec 13, 2010 — Recall Campaign #10V634000

PACCAR IS RECALLING CERTAIN MODEL YEAR 2007-2008 KENWORTH AND PETERBILT VEHICLES MANUFACTURED FROM FEBRUARY 2, 2006 THROUGH APRIL 30, 2007. THE BEARING SURFACES OF THE EXTENDED LUBE UNIVERSAL JOINT THAT ATTACHES THE INTER-AXLE DRIVELINE TO THE DRIVE AXLE MAY BECOME PREMATURELY WORN DUE TO BREAKDOWN OF LUBRICATION AND/OR EXCESSIVE HEAT. PREMATURELY WORN BEARING SURFACES MAY RESULT IN THE U-JOINT BECOMING LOOSE AND/OR BINDING. THIS CONDITION MAY RESULT IN UNIVERSAL JOINT FAILURE, ALLOWING THE INTER-AXLE DRIVELINE TO DETACH FROM THE AXLE.

The recall was influenced by the Office of Defects Investigation with about 12,873 units affected.

See recall notice

NHTSA Safety Recall Notice

10V634000

Manufacturer:	PACCAR Incorporated
Recall date:	December 13, 2010
NHTSA Campaign #:	10V634000
Units affected:	12,873

Description:: PACCAR IS RECALLING CERTAIN MODEL YEAR 2007-2008 KENWORTH AND PETERBILT VEHICLES MANUFACTURED FROM FEBRUARY 2, 2006 THROUGH APRIL 30, 2007. THE BEARING SURFACES OF THE EXTENDED LUBE UNIVERSAL JOINT THAT ATTACHES THE INTER-AXLE DRIVELINE TO THE DRIVE AXLE MAY BECOME PREMATURELY WORN DUE TO BREAKDOWN OF LUBRICATION AND/OR EXCESSIVE HEAT. PREMATURELY WORN BEARING SURFACES MAY RESULT IN THE U-JOINT BECOMING LOOSE AND/OR BINDING. THIS CONDITION MAY RESULT IN UNIVERSAL JOINT FAILURE, ALLOWING THE INTER-AXLE DRIVELINE TO DETACH FROM THE AXLE.
Consequeces:: DETACHMENT OF THE DRIVELINE FROM THE AXLE MAY CAUSE THE VEHICLE TO LOSE POWER AND BECOME DISABLED IN THE ROADWAY. ALSO, THE DRIVELINE COULD DROP FROM THE VEHICLE INTO THE ROADWAY INCREASING THE RISK OF A CRASH.
Corrective action:: PACCAR IS WORKING WITH ITS SUPPLIER TO REMEDY THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2011. OWNERS MAY CONTACT KENWORTH AT 425-828-5440 AND PETERBILT AT 940-591-4196.
Notes:: KENWORTH RECALL NO. 10KWL & PETERBILT RECALL NO. 1201F.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2008 KENWORTH T2000 Complaints
TL* THE CONTACT OWNS A 2008 KENWORTH T2000. THE CONTACT STATED THAT THE FUEL BURNING CHAMBER MALFUNCTIONED AND CAUSED THE CHECK ENGINE LIGHT TO CONTINUOUSLY ILLUMINATE. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE EXHAUST TEMPERATURE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 674,692. UPDATED 06/17/14 MA UPDATED 8/21/17*CN;
2008 KENWORTH T600 Complaints
MY TRUCKE HAD BEEN SHUT OFF AT 10:00-10:15PM AND THE FIRE STARTED SOMETIME BETWEEIN 2:00-2:1AM.WHEN I WOKE UP AND LOOKED OUT AT THE HOOD, 2 FOOT FLAMES WERE COMING OUT OF THE HOOD ENGINE SIDE OF THE FIRE WALL ON THE PASSENGER SIDE. MOTOR WAS SHUT OFF AND NOTHING ELSE WAS RUNNING. I BELIEVE THE PROBLEM WAS COMING FROM THE ENGINE REGEN. MOTOR WAS A 550 CATERPILLAR IN A 2008 KW STUDIO SLEEPER MA 10/19/2015 UPDATED 4/27/18*JB *TR;
2008 KENWORTH T660 Complaints
2008 KENWORTH T660 WITH A CATERPILLAR C-15 ENGINE. CONSUMER STATES TRUCK CAUGHT FIRE AFTER ACCIDENT *TGW THE CONSUMER STATED A TANKER TRUCK SUDDENLY STOPPED UNEXPECTEDLY AND THE CONSUMERS HUSBAND HIT THE TANKERS BUMPER. SMOKE AND FLAMES STARTED POURING OUT FROM UNDER THE GOOD OF THE TRACTOR. THE CONSUMERS HUSBAND GRABBED THE EXTINGUISHER, RAN TO THE FRONT OF THE TRUNK, BUT BECAUSE OF THE SMOKE AND FLAMES, HE WAS UNABLE TO OPEN THE HOOD. HE DISCHARGED THE FIRE EXTINGUISHER UNDER THE DRIVER'S SIDE WHEEL WELL, BUT THE ENTIRE TRACTOR WAS SOON ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES AND THE TRACTOR WAS TOWED TO AN IMPOUND YARD. THE INSURANCE INVESTIGATORS COULD NOT DETERMINE THE CAUSE OF THE FIRE, DUE TO THE AMOUNT OF FIRE DAMAGE TO THE ENGINE. *JB;
2008 KENWORTH T800 Complaints
2008 KENWORTH T800B. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE TO INCLUDE LIQUID NATURAL GAS LEAKS *TGW THE CONSUMER STATED HE WAS PROMISED A WARRANTY ON THE LNG SYSTEM BY THE MANUFACTURER OF THE LNG SYSTEM IN THE TRUCK. HE WAS INFORMED HE COULD ONLY GET THE TRUCK SERVICED BY KENWORTH. HE HAS EXPERIENCED NUMEROUS PROBLEMS WITH THE LNG SYSTEM INCLUDING LIQUID GAS LEAKS OVERNIGHT WHICH CAUSED FREEZING ON THE TANK. SEVERAL VACUUMS HAD BEEN PERFORMED ON THE TANK TO TRY AND GET THE TANK TO WORK, BECAUSE NO ONE WANTED TO REPLACE THE TANK. *JB;