CHAMPION BUS IS RECALLING CERTAIN VEHICLES BUILT ON FREIGHTLINER S2 CHASSIS AND EQUIPPED WITH TRW IGEN3
— Recall Campaign #10V647000
CHAMPION BUS IS RECALLING CERTAIN VEHICLES BUILT ON FREIGHTLINER S2 CHASSIS AND EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)
The recall was influenced by the manufacturer with about 12 units affected.
NHTSA Safety Recall Notice
10V647000
| Manufacturer: | Champion Bus, Inc. |
|---|---|
| Recall date: | December 21, 2010 |
| NHTSA Campaign #: | 10V647000 |
| Units affected: | 12 |
- Description:
- CHAMPION BUS IS RECALLING CERTAIN VEHICLES BUILT ON FREIGHTLINER S2 CHASSIS AND EQUIPPED WITH TRW IGEN3 INTERMEDIATE STEERING COLUMNS. THE WELD AROUND THE IGEN3 STEERING SHAFT TUBE THAT SECURES THE SPLINE TUBE TO THE INTERMEDIATE TUBE MAY BE MISLOCATED (I.E., NOT FULLY OVER THE SEAM CREATED WHEN THE TUBES ARE PRESSED TOGETHER.)
- Consequeces:
- MISLOCATED WELDS MAY RESULT IN TORSIONAL AND AXIAL STRENGTH FALLING BELOW ACCEPTABLE LEVELS. THIS CONDITION COULD RESULT IN SEPARATION OF THE STEERING COLUMN, LOSS OF STEERING CONTROL AND A VEHICLE CRASH WITHOUT WARNING.
- Corrective action:
- DAIMLER TRUCKS/FREIGHTLINER WILL HANDLE THE REMEDY AND QUARTERLY REPORTS FOR THIS CAMPAIGN. PLEASE SEE FREIGHTLINER'S DEFECT REPORT (10V-322). FREIGHTLINER WILL NOTIFY OWNERS AND THE BUSES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 23, 2010. OWNERS MAY CONTACT DAIMLER TRUCKS/FREIGHTLINER AT 1-800-547-0712.
- Notes:
- OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .