KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010-2011 COUGAR, LAREDO AND OUTBACK TRAVEL TRAILERS EQUIPPED

Jan 04, 2011 — Recall Campaign #11V002000

KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010-2011 COUGAR, LAREDO AND OUTBACK TRAVEL TRAILERS EQUIPPED WITH LIPPERT COMPONENT HITCH COUPLERS FOR LACK OF INDENTATION ON THE FORWARD EDGE OF THE COUPLER.

The recall was influenced by the manufacturer with about 1,086 units affected.

See recall notice

NHTSA Safety Recall Notice

11V002000

Manufacturer:	Keystone RV Company
Recall date:	January 04, 2011
NHTSA Campaign #:	11V002000
Units affected:	1,086

Description:: KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010-2011 COUGAR, LAREDO AND OUTBACK TRAVEL TRAILERS EQUIPPED WITH LIPPERT COMPONENT HITCH COUPLERS FOR LACK OF INDENTATION ON THE FORWARD EDGE OF THE COUPLER.
Consequeces:: IF THE COUPLER IS LACKING THE INDENT IT WILL LEAD TO AN INCREASED RISK OF TRAILER SEPARATION FROM THE HITCH BALL WHILE TOWING RESULTING IN PROPERTY DAMAGE AND/OR VEHICLE CRASH.
Corrective action:: OWNERS ARE ASKED TO INSPECT THE HITCH COUPLER FOR THE CORRECT STAMPING. IF THE HITCH COUPLER IS NOT FORMED CORRECTLY ARRANGEMENTS WILL BE MADE TO REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 24, 2011. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Notes:: KEYSTONE SAFETY RECALL NO. 10-156.OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2011 KEYSTONE COUGAR Complaints
THE SPARE TIRE HAS A COVER AND THE TRAILER HAS ALWAYS BEEN STORED IN A TEMPERATURE-CONTROLLED GARAGE. THE TIRE WAS INSTALLED ON THE TRAILER (IN THE RIGHT REAR POSITION) FOR THE FIRST TIME, PRESSURE CHECKED (65 PSI), AND DRIVEN 25-30 MILES ON I-25 AT 60-62 MPH BEFORE SUFFERING A CATASTROPHIC BLOW-OUT (ACCOMPANIED BY A VERY LARGE "BANG"). THE ENTIRE TREAD AREA PEELED OFF THE TIRE AND A LARGE HOLE REMAINED IN THE TREAD AREA OF THE CARCASS WITH JAGGED STEEL BELT CORDS PROTRUDING. WHILE GETTING THE TRAILER STOPPED, THE FLAILING TIRE (VISIBLE IN THE REARVIEW MIRROR) REPEATEDLY STRUCK THE SIDE OF THE TRAILER. THE WHEEL MOLDING ON THE SIDE OF THE TRAILER ABOVE THE WHEELS WAS TORN OFF AND DISINTEGRATED. THE ALUMINUM PANEL ABOVE THE WHEELS WAS BADLY DAMAGED AND COMPACTED INTO THE AREA BEHIND THE WHEEL AND IN FRONT OF THE ACCESS STEPS. THE STEPS AND MAIN ACCESS DOOR WERE ALSO DAMAGED. THE UNDERBODY AREA WAS DAMAGED IN THAT THE BELLY COVERING AND INSULATION WERE SHREDDED. THIS TIRE WAS A POWER KING TOWMAX STR SIZE ST225/75R15 IDENTIFIED BY DOT 83B4GPB1010.;
2011 KEYSTONE LAREDO Complaints
The driver side main support beam that runs the entire length of the trailer from front to back cracked. Also, many of the support beams that run the width of the trailer were twisted and nearly falling off. We had to replace the entire main support beam on the driver side as well as smaller supports that ran the width of the trailer. The first repair was in June 2022 for the smaller support beams. The second repair was in April 2023 for the long, driver side support beam.;
2011 KEYSTONE OUTBACK Complaints
WHILE DRIVING 65 MPH ON THE HIGHWAY, I EXPERIENCE CATASTROPHIC FAILURE OF THESE TRAILER TIRES. TIRES WERE INFLATED TO MANUFACTUER INSTRUCTIONS 65 PSI. PRE TRIP INSPECTION SHOWED NO CRACKS OR DRY ROTTING. THERE WAS NO INDICATION OF ANY DEFECT. VEHICLE WAS NOT OVERLOADED. AFTER REPLACING THE FIRST BLOW OUT, A SECOND TIRE CATASTROPHICALLY FAILED WITHIN 30 MILES OF THE FIRST. CAMPER SUSTAINED DAMAGE TO THE WHEEL WELL, EXTERIOR TRIP, SOME LIGHTING WIRING AND PUT A HOLE IN THE FLOOR FROM UNDERNEATH.;