ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER

May 31, 2011 — Recall Campaign #11V307000

ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.

The recall was influenced by the manufacturer with about 15 units affected.

See recall notice

NHTSA Safety Recall Notice

11V307000

Manufacturer:	Ford Motor Company
Recall date:	May 31, 2011
NHTSA Campaign #:	11V307000
Units affected:	15

Description:: ROUSH PERFORMANCE PRODUCTS IS RECALLING CERTAIN 2011 FORD E-SERIES VANS EQUIPPED WITH 5.4 OR 6.8 LITER ENGINES THAT HAVE BEEN ALTERED BY ROUSH TO OPERATE USING THE ROUSH LIQUID PROPANE AUTOGAS FUEL SYSTEM. A VALVE IN THE SYSTEM MAY HAVE BEEN MISMACHINED ALLOWING A PROPANE LEAK.
Consequeces:: A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE MAY RESULT IN A VEHICLE FIRE.
Corrective action:: ROUSH WILL REPLACE THE DEFECTIVE VALVE WITH A CORRECTLY MACHINED ONE. ALL THE AFFECTED VEHICLES HAVE BEEN REPAIRED, THEREFORE, AN OWNER NOTIFICATION LETTER WILL NOT BE ISSUED FOR THIS CAMPAIGN. OWNERS MAY CONTACT ROUSH AT 1-734-466-6255.
Notes:: OWNERS MAY ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S VEHICLE SAFETY HOTLINE AT 1-888-327-4236 (TTY 1-800-424-9153), OR GO TO HTTP://WWW.SAFERCAR.GOV .

Affects the following:

2011 FORD E-150 Complaints
WHEN ENGINE IS STARTED IN THE MORNINGS YOU CAN HEAR A KNOCKING SOUND WHICH SEEMS TO SUBSIDE AS THE ENGINE IS WARMING. I'VE BEEN WATCHING THE VIDEO ON YOUTUBE ABOUT THE CATASTROPHIC CONSEQUENCES THIS WILL EVENTUALLY OCCUR IF THE CAUSE IS NOT DISCOVERED AND REPAIRED. PLEASE REFER TO YOUTUBE VIDEOS FORDTECHMAKEULOCO SEE THE 2004-2015 TITLED FORD F-150/E-150 LOWER BALLJOINT REPLACEMENT AND HOW A FAILED $4.00 PART TURNED INTO A $7,000 MOTOR REPAIR. OIL PUMPS ALSO. HAPPENS IN THE DRIVEWAY IDLING . FORD DEALER WANTED $125. TO DIAGNOSE THIS MORNING THURSDAY 12/10/2020.;
2011 FORD E-250 Complaints
THE PCM AT 34,000 MILES CAUSED TWO FUEL PUMPS TO BURN OUT IN 4 DAYS. A "WRENCH" WARNING SYMBOL APPEARED ON THE DASH AND THE VANS ENGINE DIES WHILE GOING AT HIGH SPEED (WE PULL A PRESSURE WASHING TRAILER HOLDING WITH HAZARDOUS CHEMICALS & WATER). IF IT WAS RAINING OR EVEN HEAVY TRAFFIC THIS COULD CAUSE A DANGEROUS LIFE THREATENING CRASH. ON WET ROADS THESE HEAVY COMMERCIAL VEHICLES CAN EASILY HYDRO-PLAIN WHEN THIS OCCURS PUTTING THE DRIVER & OTHERS IN DANGER WHO MAY BE IN THE PATH. WE ARE NOW WITHOUT OUR SERVICE VAN FOR 2 WEEKS & FORD ESTIMATED IN THE EXCESS OF $2600 IN REPAIRS ON A VEHICLE WITH JUST 34,000 MILES ON THE VAN.WE JUST REPLACED THE TRANSMISSION 3 MONTHS AGO. MY STEP FATHER IS 84 YEARS OLD WHO OWNS THIS VEHICLE AND HE IS A RETIRED NAVY CAPTAIN OF OVER 25 YEARS. HE AND I ARE BOTH CONCERNED THAT THIS VEHICLE IS TOO DANGEROUS TO DRIVE AT HIGH SPEEDS (60-70MPH) WITH THE LOADS WE CARRY IN OUR EVERY DAY SERVICE SCHEDULE. FORD SEEMS TO OFFER NO ASSISTANCE FINANCIALLY AND NO COMFORT IN RESOLVING THE SAFETY ISSUES RESULTING IN THE FAILURE OF THE PCM (POWER TRAIN CONTROL MODULE) WHICH IS OBVIOUSLY VERY DANGEROUS WHEN LARGE COMMERCIAL VEHICLES HAVE THE ENGINE FAILING OR DYING AT HIGH SPEEDS. AFTER READING ABOUT THE THROTTLE BODY PROBLEMS THAT FORD EXPERIENCING WITH OVER 1,600,000 VEHICLES BEING RECALLED, IT SEEMS THAT THE SAME WARNING SYMBOL OF THE TWO SIDED WRENCH APPEARS ON THE DASH AND THE SAME ENGINE FAILING OCCURS AT HIGH SPEEDS. THE SERVICE MECHANIC AT BIG STAR FORD IN MANVEL TX. TOLD ME HE REPLACED THE FIRST FUEL PUMP, DROVE IT ON THE HWY AND HAD TO TOW IT BACK TO THE DEALER BECAUSE IT DIED WHILE TEST DRIVING THE VAN AND BURNED OUT THE NEW FUEL PUMP HE JUST INSTALLED, THEN HE SAID HE PUT A NEW FUEL PUMP IN AGAIN AND USED THAT TO DIAGNOSE THAT THE PCM WAS THE PROBLEM WHILE RUNNING IT ON IDLE FOR AN HOUR. WE ARE NOW CONCERNED THIS NEW PUMP IS DAMAGED.;
2011 FORD E-350 Complaints
The brakes are faulty. Have tried to have them repaired 3 times and it ends with the same problem. The brakes go all the way in and have to be pumped to stop.;
2011 FORD E-450 Complaints
WHILE DRIVING STRAIGHT ON A CITY STREET AND AGAIN ON AN INTERSTATE, THE VEHICLE SHUT OFF. A DIAGNOSTIC REPORT DETERMINED THAT THE FUEL PUMP CIRCUIT WIRING HARNESS WAS BAD. THE VEHICLE HAS 23,000.;