General Motors LLC is recalling certain model year 2012-2013 Chevrolet Silverado HD and GMC Sierra

Dec 11, 2013 — Recall Campaign #13V615000

General Motors LLC (GM) is recalling certain model year 2012-2013 Chevrolet Silverado HD and GMC Sierra HD vehicles, equipped with 6.6L diesel engines and dual fuel tanks. In the affected vehicles, the transfer pump which moves fuel from the rear tank to the front tank could malfunction and cause the fuel gauge to indicate an inaccurate reading.

The recall was influenced by the manufacturer with about 9,733 units affected.

See recall notice

NHTSA Safety Recall Notice

13V615000

Manufacturer:	General Motors, LLC
Recall date:	December 11, 2013
NHTSA Campaign #:	13V615000
Units affected:	9,733

Description:: General Motors LLC (GM) is recalling certain model year 2012-2013 Chevrolet Silverado HD and GMC Sierra HD vehicles, equipped with 6.6L diesel engines and dual fuel tanks. In the affected vehicles, the transfer pump which moves fuel from the rear tank to the front tank could malfunction and cause the fuel gauge to indicate an inaccurate reading.
Consequeces:: If the fuel gauge indicates an inaccurate reading it may result in the vehicle unexpectedly stalling, increasing the risk of a crash.
Corrective action:: General Motors will notify owners and dealers will inspect and replace the fuel transfer pump, as necessary, free of charge. The manufacturer has not yet provided a notification schedule. The recall began on May 30, 2014. Owners may contact Chevrolet at 1-800-222-1020 and GMC at 1-800-462-8782. GM's number for this recall is 13420.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2013 CHEVROLET SILVERADO 1500 Complaints
The vehicle's structural frame rails have suffered a catastrophic failure. The driver-side frame rail has a physical separation gap measuring between 1/2-inch and 1 inch wide. The passenger-side frame rail is actively delaminating and separating from the inside out. The vehicle and the failed component are completely intact and available for immediate inspection upon request. SAFETY RISK TO OTHERS:The structural integrity of the truck is entirely gone, creating an extreme safety hazard. If driven, the frame is at risk of snapping completely in half, which would cause an immediate, catastrophic loss of steering, suspension control, and braking on public roads, risking a fatal crash for the occupants and nearby drivers. CONFIRMATION BY A SERVICE CENTER:The problem has not been visually confirmed via a safety inspection. The catastrophic splitting aligns exactly with the premature corrosion patterns caused by the failing factory wax defect openly documented by General Motors in Technical Service Bulletin (TSB) 19-NA-255.4. INSPECTION BY MANUFACTURER/POLICE/INSURANCE:The vehicle has not yet been inspected by General Motors corporate, local police, or insurance representatives. It was immediately deemed unroadworthy and taken off public roads and parked. WARNING LAMPS AND PRIOR SYMPTOMS: There were no warning lamps, or dashboard messages. The only symptoms was when going over a bump it made a weird noises which was inspected and found the crumbling/failing frame. Because the multi-layered steel frame rots from the inside out due to moisture trapped behind the defective factory wax coating, the structural failure remained entirely invisible until the frame physically cracked open and separated.;
2013 GMC SIERRA 1500 Complaints
Failure of frame on left side of vehicle between frame rail and fuel tank. For a approx 10 year old vehicle that is garaged and does not drive in inclement weather this SHOULD NOT be happening.;