Volkswagen Group of America, Inc. is recalling certain model year 2015-2016 Jetta

Oct 26, 2015 — Recall Campaign #15V705000

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.

The recall was influenced by the manufacturer with about 91,867 units affected.

See recall notice

NHTSA Safety Recall Notice

15V705000

Manufacturer:	Volkswagen Group of America, Inc.
Recall date:	October 26, 2015
NHTSA Campaign #:	15V705000
Units affected:	91,867

Description:: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.
Consequeces:: If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.
Corrective action:: Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2016 VOLKSWAGEN BEETLE Complaints
The contact owns a 2016 Volkswagen Beetle. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 22V945000 (Air Bags); however, the repair failed to prevent a failure. The contact stated that the vehicle experienced an air bag failure shortly after the recall repair. The vehicle was taken back to the same local dealer, where it was diagnosed with a driver’s side air bag failure. The vehicle was not repaired. The failure mileage was approximately 30,000.;
2016 VOLKSWAGEN GOLF SPORTWAGEN Complaints
SRS/airbag warning light illuminated. A diagnostic scan (VCDS) confirmed stored fault codes for both front airbag crash sensors: driver's side 'short to ground' and passenger's side 'open or short to plus.' Upon further inspection, water was found pooled at the airbag control module connector, located under the center dash. The AC condensate drain line is routed directly above this module, and appears to be the source of the water intrusion — water drained from the connector itself when disconnected, and dampness was present at both the upper and lower AC drain hose connections near the module. After drying and reconnecting all components, an attempt was made to clear the fault codes via VCDS. The airbag module returned a 'not acknowledged' response to the clear command, indicating the fault condition and/or internal component damage may still be present. This vehicle's VIN was checked against active airbag recalls for this model year and found not to be included. However, given the safety-critical nature of the SRS system and the apparent design proximity of the AC drain to the airbag module connector, this may represent a broader risk for this chassis. Multiple independent repair shops declined to service this issue, citing liability concerns related to airbag system water intrusion. Volkswagen customer service denied a goodwill repair request, citing vehicle age/mileage without reviewing supporting documentation (VCDS diagnostic report and photos).;
2016 VOLKSWAGEN JETTA Complaints
I tried to stop my car and the brake pedal went completely to the floor and did not stop at all. There were no warning lights on, I keep my brakes and car well maintained. My car hit the rear of another car because the brakes failed to engage when I pushed the pedal down. My car which is the vw jetta was totaled in the accident. My insurance company GEICO has the car sitting at copart and it should be able to be inspected. I know the 2015-2016 vw Jetta had a recall for brake failure due to brake vacuum pump.But my 2016 doesn’t have any recalls on it. The police officer inspected the brakes at the scene.;
2016 VOLKSWAGEN PASSAT Complaints
The clock spring system failed, rendering all of the cars' steering wheel functions non-functional. The airbag light is on and the steering wheels airbag does not operate as well as the cars horn and auto cruise controls. The instrument cluster is malfunctioning as well. The safety risks associated with the malfunctions could result in great harm to the driver and passengers in the vehicle.;