Thor Motor Coach is recalling certain model year 2014-2016 Hurricane and Windsport motor homes

Mar 07, 2016 — Recall Campaign #16V139000

Thor Motor Coach (TMC) is recalling certain model year 2014-2016 Hurricane and Windsport motor homes manufactured January 30, 2013, to March 6, 2015. In the affected motor homes, the vehicle exhaust is located near a storage compartment where heat may build-up, causing the compartment to melt.

The recall was influenced by the manufacturer with about 385 units affected.

See recall notice

NHTSA Safety Recall Notice

16V139000

Manufacturer:	Thor Motor Coach
Recall date:	March 07, 2016
NHTSA Campaign #:	16V139000
Units affected:	385

Description:: Thor Motor Coach (TMC) is recalling certain model year 2014-2016 Hurricane and Windsport motor homes manufactured January 30, 2013, to March 6, 2015. In the affected motor homes, the vehicle exhaust is located near a storage compartment where heat may build-up, causing the compartment to melt.
Consequeces:: Heat build-up in the vehicle storage compartment increases the risk of fire.
Corrective action:: TMC will notify owners, and dealers will install a heat shield to prevent heat build-up in the storage compartment. The recall began on April 20, 2016. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000112.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2015 THOR MOTOR COACH HURRICANE Complaints
THE ENTRANCE LOCK FALLED LEAVING OCCUPANT LOCKED OUT OF MOTORHOME. HAD TO PRY LOCK FROM DOOR. PERSONS COULD HAVE BEEN LOCKED INSIDE...VEHICLE WAS PARKED. IF VEHICLE HAD BEEN IN AN ACCIDENT THEN THE OCCUPANTS WOULD HAVE BEEN LOCKED INSIDE WITHOUT AN ESCAPE ROUTE...;
2016 THOR MOTOR HURRICANE Complaints
On December 13, 2021 the windshield wipers failed while we were driving at about 55 mph on a highway in heavy rain and wind. The passenger side wiper arm over-traveled and jammed behind the driver side wiper arm leaving us with no windshield wipers. We pulled onto the shoulder and unjammed the wipers several times but each time they jammed again within a few minutes. We drove without wipers to the nearest exit where we spent the night on the side of the road. The next morning after the rain stopped we drove to an independent RV repair shop where the technician: "Inspected all linkages, pivot points and mounting points. Found motor linkage bent. Straightened bracket and tightened passenger side spline mount." The next time we drove in the rain, on December 29, 2021, the same thing happened after using the wipers for less than an hour. We exited the highway and drove on a secondary road to our destination in the rain without wipers. We cannot drive the vehicle in the rain in this condition again. We will contact a Thor authorized service center to arrange an inspection and repair.;
2016 THOR MOTOR COACH WINDSPORT Complaints
The windshield wipers get out of sync and collide, usually it ends up with the passenger wiper stuck down behind the driver's wiper and they both stop with no way to clear the rain from the windshield. There have been recalls issued for my model & year of RV but THOR says they don't apply to my RV. This has happened several times. My "solution" is to remove the passenger wiper.;