Volkswagen Group of America, Inc. is recalling certain model year 2009-2012 Audi Q5

Sep 13, 2016 — Recall Campaign #16V660000

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.

The recall was influenced by the manufacturer with about 143,214 units affected.

See recall notice

NHTSA Safety Recall Notice

16V660000

Manufacturer:	Volkswagen Group of America, Inc.
Recall date:	September 13, 2016
NHTSA Campaign #:	16V660000
Units affected:	143,214

Description:: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2009-2012 Audi Q5, and 2007-2012 Audi Q7 vehicles equipped with gasoline engines. The fuel pump flange on the affected vehicles may crack, allowing fuel to leak.
Consequeces:: A fuel leak in the presence of an ignition source increases the risk of a fire.
Corrective action:: Audi will notify owners, and dealers will inspect the flange, replacing any flanges that are cracked. If the flange is not cracked, dealers will clean the pump flange and install a butyl rubber band to protect the pump. These repairs will be made free of charge. The recall began November 9, 2016. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 20W9.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2012 AUDI Q5 Complaints
The vehicle sunroof exploded. On March 10th at approximately 12:15pm, while driving down the road from my residence in my 2012 Audi Q5, the sunroof blew up, without warning, causing shattered glass to fall inside the cab of the vehicle onto myself, and my then nine year old son, causing minor cuts, and small pieces of glass to be lodged into the skin of our arms, chest, and head . I called the Audi service ref repairs, and was told it would take three months, before the service department could look at and repair my vehicle, as they were backed up with repairs. I ordered a new sunroof windshield and did a self repair and calibration. I followed up with Audi, advising of the incident, and was told the SUNROOF was under a recall, but their records, this item had been address on my vehicle, no further assistance was offered.;
2012 AUDI Q7 Complaints
On or December 5th, 2025 (4 days after taking possession of the vehicle, I experienced a sudden and severe steering system failure while driving. When turning the steering wheel (even slightly), the vehicle produced a loud buzzing/grinding noise and the steering effort increased significantly, creating an immediate safety hazard. Because the steering issue worsened quickly and made the vehicle difficult to control, I stopped driving and brought the vehicle to an authorized Audi dealership for inspection. The Audi dealership confirmed the steering failure was caused by a major power steering system defect, including active power steering fluid leakage from the steering rack area consistent with internal seal failure, and the power steering pump being faulty due to fluid loss. The dealership advised replacement of the power steering rack and pump and stated the vehicle was unsafe to test drive due to its condition. During the same inspection, the Audi dealership also identified additional serious safety-related defects, including a brake system condition where the brake pedal slowly sinks toward the floor when pressure is applied (indicating a braking system performance failure requiring brake fluid exchange and further diagnosis if unresolved). The inspection also documented multiple additional mechanical and safety concerns requiring extensive repairs, including suspension and drivetrain defects and other conditions indicating the vehicle was not roadworthy as sold. The vehicle remains available for inspection. This incident involved a sudden loss of steering assist and braking abnormalities that could lead to loss of control, crash risk, and injury to the driver, passengers, and other motorists.;