Kia Motors America is recalling certain 2017 Sorento vehicles equipped with 3.3L engines

Sep 21, 2017 — Recall Campaign #17V586000

Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.

The recall was influenced by the manufacturer with about 62 units affected.

See recall notice

NHTSA Safety Recall Notice

17V586000

Manufacturer:	Kia America, Inc.
Recall date:	September 21, 2017
NHTSA Campaign #:	17V586000
Units affected:	62

Description:: Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.
Consequeces:: If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.
Corrective action:: Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall began November 6, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC153.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2017 KIA SORENTO

2017 KIA SORENTO Complaints
In early July, my vehicle's check engine light turned on. I took it to a reputable local mechanic in Sachse, Texas, who had the vehicle for approximately two weeks. He was unable to determine the cause of the issue but informed me that there was an existing recall and that the dealership should be able to address the problem at no cost to me. I then took the vehicle to the Kia dealership. The dealership informed me that there was an extended warranty for the engine and that if their diagnosis determined that the issue was covered under the warranty extension, they would repair it. This is what they texted me: Tech performed Compression test 1 .205psi, 2. 220psi, 3. 260psi, 4. 255psi all cylinders have excessive reading for dry compression test. Tech performed leak down test on all cylinders 1. 21% leak down coming from exhaust side, 2.61% leak down coming from exhaust side, 3. 10% normal, 4. 10% normal. Air leakage from exhaust system defective exhaust valves. Tech performed Cooling system pressure test for 20 minutes with no pressure loss. Ruling out head gasket. Tech evaluated Intake/Exhaust CVVT current and setpoints. Tech determined timing is jumping from back pressure of Clogged Catalyst Converter. Recommending replacing engine due to mileage and exhaust manifold. The dealership's recommended solution was to replace the entire engine. Currently, there is a recall concerning 2017 Kia Sorentos involving engine crankshaft issues. See NHTSA Recall No. 17V586000. I contacted the manufacturer, and they stated that they do not believe my vehicle is covered by the recall. However, I believe the issues identified with my vehicle may be related to the same underlying engine problems addressed by the recall, and I am concerned that the manufacturer is denying coverage rather than properly addressing the issue under the applicable recall or warranty. My engine is experiencing issues that appear similar to those described in the current NHTSA.;