Newmar Corporation is recalling certain 2017 Bay Star

Dec 26, 2017 — Recall Campaign #17V843000

Newmar Corporation (Newmar) is recalling certain 2017 Bay Star, Bay Star Sport, and Canyon Star vehicles, built on Ford chassis and equipped with Antilock Brake Systems (ABS). The brake Hydraulic Electronic Control Units (HECU) on these vehicles may be missing valve block ball plugs, potentially causing a brake fluid leak or air ingestion during electronic brake distribution and/or ABS activation.

The recall was influenced by the manufacturer with about 30 units affected.

See recall notice

NHTSA Safety Recall Notice

17V843000

Manufacturer:	Newmar Corporation
Recall date:	December 26, 2017
NHTSA Campaign #:	17V843000
Units affected:	30

Description:: Newmar Corporation (Newmar) is recalling certain 2017 Bay Star, Bay Star Sport, and Canyon Star vehicles, built on Ford chassis and equipped with Antilock Brake Systems (ABS). The brake Hydraulic Electronic Control Units (HECU) on these vehicles may be missing valve block ball plugs, potentially causing a brake fluid leak or air ingestion during electronic brake distribution and/or ABS activation.
Consequeces:: A brake fluid leak or air ingestion can lengthen the distance needed to stop the vehicle, increasing the risk of a crash.
Corrective action:: Newmar will notify owners, and Ford or Lincoln dealers will inspect the HECU for missing valve block ball plugs, replacing the unit as necessary, free of charge. The recall began on January 24, 2018. Owners may contact Ford customer service at 1-866-436-7332 or Newmar customer service at 1-800-731-8300. Newmar's number for this recall is 17V-768.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2017 NEWMAR BAY STAR Complaints
THE VEHICLE HAS AN INTERMITTENT PROBLEM WITH A SEVERE STAGGER ON TAKE OFF FROM A DEAD STOP. THE PROBLEM OCCURS FAIRLY INFREQUENTLY, BUT WHEN IT DOES OCCUR IT CAN PREVENT THE VEHICLE FROM ACCELERATING FOR UP TO A BLOCK IN DISTANCE. DURING THIS TIME THE VEHICLE ACTS AS THOUGH IT IS GOING TO DIE AND WILL ONLY TRAVEL 2 - 5 MILES PER HOUR. EVENTUALLY, IT WILL RESUME ACCELERATION AND DRIVE NORMALLY. HOWEVER, IT IS A SEVERE DANGER TO THE VEHICLE'S OCCUPANTS SINCE THIS CAN OCCUR WHEN PULLING OUT TO TURN RIGHT OR LEFT OR EVEN GO THROUGH AN INTERSECTION ON A GREEN LIGHT, WHICH MIGHT TURN RED BY THE TIME THE VEHICLE DECIDES TO ACCELERATE NORMALLY. I HAVE TAKEN IT TO THE FORD DEALER IN DALLAS, OREGON, TWICE TO HAVE IT REPAIRED. THEY HAVE RUN DIAGNOSTICS ON THE FLIGHT RECORDER AND HAVE BEEN UNABLE TO DETECT THE PROBLEM. SINCE IT IS AN INTERMITTENT PROBLEM THIS IS NOT BEYOND THE SCOPE OF REASON. I HAVE TALKED WITH A NUMBER OF MECHANICS OUTSIDE OF THE FORD ORGANIZATION, AND MOST OF THEM HAVE STATED THAT THEY BELIEVE THE PROBLEM TO BE THE THROTTLE POSITIONING SENSOR. I HAVE SUGGESTIVE THIS TO FORD AND ITS DEALERSHIP, BUT THEY STATE THAT THEY CANNOT REPLACE THE SENSOR WITHOUT FIRST HAVING THE FLIGHT RECORDER DETECT THE EXACT PROBLEM. I HAVE OFFERED TO PAY THE DEALERSHIP FOR THE PART AND LABOR, EVEN THOUGH I AM STILL IN WARRANTY, BUT THEY REFUSE TO REPLACE IT. IN THE MEANTIME MY WIFE AND I ARE EXPOSED TO AN EXTREME RISK WHILE OPERATING OUR NEW MOTORHOME. THE DEALERSHIP WANTS US TO DRIVE THE 150 MILES FROM OUR HOME AND LEAVE THE VEHICLE WITH THEM TO TEST IT AT THEIR CONVENIENCE WHILE THEIR MECHANICS HAVE A LULL IN THEIR DAILY SCHEDULE. TO DO THIS WITHOUT A SCHEDULED TIME WITH AN INTERMITTENT PROBLEMS COULD TAKE MONTHS. I HAVE ASKED FORD TO SUPPLY US WITH THE LOAN OF A FORD FLIGHT RECORDER TO USE UNTIL THE PROBLEM CAN BE DETECTED, BUT THEY HAVE REFUSED TO DO SO.;
2017 NEWMAR CANYON STAR Complaints
ON MAY 3, 2021 WHILE DRIVING I-71 S IN OHIO DURING A HEAVY RAIN STORM, I EXPERIENCED A CATASTROPHIC FAILURE OF THE WINDSHIELD WIPER SYSTEM. I WAS TRAVELLING APPROX. 55 MPH. EITHER THE WIPER ARM (WHERE IT'S ATTACHED TO THE MOTOR) FAILED AND CAUSED THE BRACKET HOLDING THE MOTOR TO FAIL, OR THE BRACKET FAILED AND CAUSED THE WIPER ARMS TO FAIL. BOTH WIPERS, DRIVER'S AND PASSENGER SIDE FELL DOWN AWAY FROM THE WINDSHIELD. I WAS NOT ABLE TO SEE OUT OF THE WINDSHIELD AND HAD TO PULL OFF THE HIGHWAY.;