Volkswagen Group of America, Inc. is recalling certain 2015 Passat

Jan 11, 2019 — Recall Campaign #19V014000

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015 Passat, 2015-2016 Eos, 2015-2017 CC, 2016-2017 TT Roadster, TT Coupe, 2017 Audi R8 Coupe, and R8 Spyder vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.

The recall was influenced by the Office of Defects Investigation with about 119,394 units affected.

See recall notice

NHTSA Safety Recall Notice

19V014000

Manufacturer:	Volkswagen Group of America, Inc.
Recall date:	January 11, 2019
NHTSA Campaign #:	19V014000
Units affected:	119,394

Description:: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015 Passat, 2015-2016 Eos, 2015-2017 CC, 2016-2017 TT Roadster, TT Coupe, 2017 Audi R8 Coupe, and R8 Spyder vehicles. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to explode.
Consequeces:: In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could explode with metal fragments striking the vehicle occupants potentially resulting in serious injury or death.
Corrective action:: Volkswagen will notify owners, and dealers will replace the driver's frontal air bag inflator with an alternative inflator, free of charge. The recall began March 4, 2019. Volkswagen owners may contact Volkswagen customer service at 1-800-893-5298; Audi owners may contact Audi at 1-800-253-2834. Volkswagen's number for this recall is 69S8 (Audi) and 69Y5 (Volkswagen).
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2015 VOLKSWAGEN PASSAT Complaints
Vehicle has an excessive gasoline smell coming from the driver front of the vehicle- mechanics have not been able to determine the exact location of the problem.;
2016 VOLKSWAGEN EOS Complaints
The contact owns a 2016 Volkswagen EOS. The contact stated while the vehicle was parked, the vehicle failed to start. The contact stated that the battery was drained and was jumpstarted. The contact stated that after the battery had been recharged, several unknown warning lights illuminated on the instrument panel. The vehicle was taken to the dealer where it was diagnosed and determined that the instrument cluster had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred. The manufacturer was made aware of the failure. The failure mileage was approximately 20,000.;
2017 VOLKSWAGEN CC Complaints
The DQ250 6-speed DSG (dual clutch) automatic transmission in my 2017 Volkswagen CC Executive has catastrophically failed at 37,768 miles. COMPONENT FAILURE: The mechatronic unit, the electro-hydraulic controller that manages all gear selection and clutch engagement inside the DSG transmission has failed. The transmission is available for inspection upon request. WHAT HAPPENED: Symptoms began with intermittent failure to engage gear after stopping at intersections and stop signs. The transmission would slip out of gear or refuse to engage, leaving the vehicle momentarily unable to accelerate from a dead stop in traffic, a dangerous condition with cross-traffic approaching. The condition progressed to include an audible whining and slipping noise during downshifts, consistent with inadequate hydraulic clamping pressure on the clutch pack. The transmission then lost the ability to engage reverse gear entirely. The vehicle was driven home in forward gears only and is now inoperable and parked. SAFETY RISK: On multiple occasions, the vehicle was unable to accelerate from a complete stop at intersections with active cross-traffic. Loss of reverse gear eliminates the ability to maneuver out of dangerous situations in parking lots, driveways, and streets. This vehicle is unsafe to operate. WARNING SIGNS: No warning lamps or dashboard messages appeared prior to or during the failure. The first symptom was intermittent hesitation and slipping when attempting to engage from a stop. The condition worsened rapidly over a short period until reverse was lost completely. DEALER/MANUFACTURER CONTACT: The manufacturer was contacted. A callback was promised within two business days and was never received. The vehicle has not yet been inspected by a dealer because the servicing dealer, a Volkswagen-authorized dealership, has permanently closed. The vehicle is awaiting tow to a specialist for diagnostic confirmation. MAINTENANCE HISTORY: At SM VW until it closed. Once at Indy Shop;