Volkswagen Group of America, Inc. is recalling certain 2012-2015 Passat

Dec 04, 2019 — Recall Campaign #19V862000

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

The recall was influenced by the manufacturer with about 226 units affected.

See recall notice

NHTSA Safety Recall Notice

19V862000

Manufacturer:	Volkswagen Group of America, Inc.
Recall date:	December 04, 2019
NHTSA Campaign #:	19V862000
Units affected:	226

Description:: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2015 Passat, 2011-2014 Golf A6, and 2011-2013 Audi A3 diesel vehicles, thought to have been previously repaired under one of the Takata air bag recalls. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequeces:: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Corrective action:: Volkswagen will notify owners, and dealers will replace the driver's side air bag inflators, free of charge. The recall began December 20, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298 or Audi customer service at 1-800-253-2834. Volkswagen's numbers for this recall are 69R6, 69Q8, 69Q9, and 69Y5.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2013 AUDI A3 Complaints
The contact owns a 2013 Audi A3. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly went into LIMP Mode with the check engine warning light illuminated. The contact stated that the glow plugs failed to function and became inoperable. The vehicle was taken to several dealers, where it was diagnosed with exhaust system failure. The contact was informed that the exhaust system needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 128,000.;
2014 VOLKSWAGEN GOLF Complaints
My vehicle has (2) serpentine belts, and (2) Belt Tensioners. (1) Tensioner is for the belt that engages the Water Pump, Alternator, Power Steering and then has (3) Idler Pulleys. The other one is the AC Tensioner, that belt routes from the AC Compressor to the Crank and the AC Tensioner. The AC Compressor is a dual belt pulley. So the AC Tensioner is suppling the power for the Accessory Belt to spin, and operate the cooling system, charging system, and power steering. Recently the Accessory Belt ripped, and since the belts and the tensioners have yet to be serviced, I planned on doing both tensioners and belts. Upon replacing the components with new ones, the AC tensioner rubs against the Accessory Belt, which will def cause the belt to rip. Further investigating, I saw the original AC Tensioner has a cut out on the side of the housing made, so that the Accessory Belt will not rub against it and spin freely. I called VW Service, O Reillys, Auto Zone, Advanced Auto, and none of the tensioners have the cut out, they all have the same tensioner that is being sold. So what do I do now? Vehicle is not drivable, and without the correct part, this vehicle is unable to safely drive. Once that belt rips, cooling system won’t work, charging system and power steering. My vehicle has almost 200K and is mechanically sound, I maintain the maintenance on this vehicle to a T. Yet I am unable to purchase a part that is needed to ensure this vehicle continues to operate safely, due to a complete engineering design mistake. In which it seems to be completely covered up, because how many people will really service the tensioner. Well I did, and I would like my vehicle to run again, seeing as how the manufacturer decided to make this shortcut, and cross there fingers and hope no issues arose;
2015 VOLKSWAGEN PASSAT Complaints
Vehicle has an excessive gasoline smell coming from the driver front of the vehicle- mechanics have not been able to determine the exact location of the problem.;