BMW of North America, LLC is recalling certain 2020 X1 xDrive28i

May 20, 2020 — Recall Campaign #20V283000

BMW of North America, LLC (BMW) is recalling certain 2020 X1 xDrive28i, X1 sDrive28i, X2 xDrive28i and X2 sDrive28i, 2020 MINI Clubman Cooper S All4, 2021 MINI Hardtop 2 Door (Cooper, Cooper S, John Cooper Works and Cooper S E) and MINI Hardtop 4 Door (Cooper and Cooper S) vehicles. Due to a problem with the rollover sensor within the air bag control unit, in the event of a rollover crash, the head air bag, seat belt pretensioners and other safety systems, may not activate.

The recall was influenced by the manufacturer with about 76 units affected.

See recall notice

NHTSA Safety Recall Notice

20V283000

Manufacturer:	BMW of North America, LLC
Recall date:	May 20, 2020
NHTSA Campaign #:	20V283000
Units affected:	76

Description:: BMW of North America, LLC (BMW) is recalling certain 2020 X1 xDrive28i, X1 sDrive28i, X2 xDrive28i and X2 sDrive28i, 2020 MINI Clubman Cooper S All4, 2021 MINI Hardtop 2 Door (Cooper, Cooper S, John Cooper Works and Cooper S E) and MINI Hardtop 4 Door (Cooper and Cooper S) vehicles. Due to a problem with the rollover sensor within the air bag control unit, in the event of a rollover crash, the head air bag, seat belt pretensioners and other safety systems, may not activate.
Consequeces:: If the safety systems do not deploy as intended in a roll over crash, it may increase the risk of injury.
Corrective action:: BMW will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began July 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2020 BMW X1 Complaints
The contact owns a 2020 BMW X1. The contact stated that while driving 75 MPH, the vehicle suddenly decelerated to 10 MPH. There was no warning light illuminated. During the failure, the messages, "Chassis Stabilization: Drive Moderately," "Collision Warning System Malfunction," "Pedestrian Warning Reduced," and "Drivetrain: Continued Driving Possible" were displayed. The vehicle was pulled over into a remote emergency lane and driven 10 miles to an exit. The vehicle was towed to the dealer, where it was diagnosed with a short circuit to ground at the throttle body. The contact was informed that the throttle ground wire and controller needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 67,000.;
2020 BMW X2 Complaints
In 2026, a 2020 BMW X2 was involved in a 40-50 mph, 60-80 degree driver-side impact. The vehicle rotated 40-80 degrees to the right and struck a curb with enough force to shear both front axles and cause multiple tire explosions. Despite this catastrophic structural failure and extreme G-forces, the Supplemental Restraint System (SRS) failed completely: no front, side, or curtain airbags deployed, and seat belt pretensioners remained inactive. In contrast, all three front airbags deployed in the striking vehicle. An independent Bosch CDR download of the Airbag Control Module (ACM) confirms "Event(s) recovered: None." This indicates a total failure of the sensing algorithm to "wake up" or acknowledge a catastrophic collision, even though the vehicle was a total loss. This failure mode mirrors NHTSA Recall 20V-283 for defective rollover/lateral sensors. The vehicle was manufactured in May 2020, immediately following the COVID-19 production restart, which was a high-risk window for supply chain irregularities, suggesting the use of defective pre-shutdown sensor inventory not currently captured by the recall VIN range. The total failure of the safety system resulted in unmitigated rotational trauma, causing a traumatic brain injury (TBI) confirmed by DTI MRI showing white-matter lesions and hemorrhage, as well as multilevel spinal stenosis and disc herniations requiring surgical intervention. Loss of lordosis in neck and back. These injuries are permanent and life-altering. Crash severity is further corroborated by external telemetry: a telematics smartphone app and an iPhone both registered the high-G impact and deceleration forces that the vehicle's internal safety module ignored. The vehicle is preserved for inspection. There were no warning lamps or system messages prior to the incident. Crash was detected by iPhone that measured impact force based on G-force. The insurance app on a separate Android phone also detected the crash based on the sudden deceleration.;
2020 MINI COOPER S CLUBMAN Complaints
The contact owns a 2020 Mini Cooper S Clubman. The contact stated that upon arriving at her destination and exiting the vehicle, the driver's side door closed, and then bounced back open. After, the contact became aware that the door latches had failed to keep the door securely closed for the driver’s and passenger’s side doors. The door-ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the driver and passenger side door latches. The vehicle was repaired, but the failure reoccurred. The manufacturer was not notified of the failure. The failure mileage was unknown.;
2021 MINI COOPER Complaints
No incident occurred. On October 18th we received a high voltage battery recall notice for this car. Apparently there were some thermal events (fires) and BMW has released software to help protect the car from such an event. We have been trying to get in touch with MINI, and just recently found that the dealer closed. They left their answering machine online for about a month after. The local BMW dealer says that they cannot perform the update (MINI USA requested we ask them). MINI USA now says that the car must be trucked 300 miles away to the closest dealer. The car cannot even be driven that far because it has about 100 miles of range, the roads are 75+, and there is limited charging infrastructure. We feel that this presents an undue time and financial burden since the dealer closed down, and this is a manufacturing defect. I have repeatedly been in touch with MINI but have received very little support or advice other than spending an enormous amount of money to have the vehicle shipped out of state.;