Newmar Corporation is recalling certain 2021 Essex

Sep 29, 2020 — Recall Campaign #20V594000

Newmar Corporation (Newmar) is recalling certain 2021 Essex, Dutch Star, Mountain Aire, and London Aire motorhomes. The front leveling jacks may not be fastened correctly to the chassis, possibly causing the jacks to fail to support the weight of the motorhome.

The recall was influenced by the manufacturer with about 48 units affected.

See recall notice

NHTSA Safety Recall Notice

20V594000

Manufacturer:	Newmar Corporation
Recall date:	September 29, 2020
NHTSA Campaign #:	20V594000
Units affected:	48

Description:: Newmar Corporation (Newmar) is recalling certain 2021 Essex, Dutch Star, Mountain Aire, and London Aire motorhomes. The front leveling jacks may not be fastened correctly to the chassis, possibly causing the jacks to fail to support the weight of the motorhome.
Consequeces:: If the front jacks fail, an unexpected drop can occur, increasing the risk of an injury.
Corrective action:: Newmar will notify owners, and dealers will inspect and repair the leveling jacks as necessary, free of charge. The recall began November 9, 2020. Owners may contact Newmar customer service at 1-800-731-8300.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2021 NEWMAR DUTCH STAR Complaints
Last week I had the air dryer filter replaced at Colton Truck Terminal in Colton Ca. Subsequently, I did the complete 7 step air brake system check and discovered that during total loss of air pressure , the emergency brakes would not auto apply. I replaced the dash hand valve and the problem still persists, so I installed the original valve and took the coach back to Colton Truck Terminal to diagnose the problem. Attached is the paper work from Colton Truck Terminal diagnosing the issue and the correction of that issue. Also on that paperwork is the vehicle information. Apparently, two air lines were crossed going into the primary air tank during chassis assembly. Once corrected, the system worked properly. I did not take it to a FL dealer because the chassis is out of warranty and Colton Truck Terminal is a well respected local repair company that almost exclusively works on Class A diesel pusher chassis. My hopes are that FL will reimburse me for this repair that was required as a result of improper initial assembly. My other concern is that there are no other chassis that may have this issue that were built around the same period. Though the emergency brakes could still be manually applied during loss of air pressure, the incorrect assembly prohibited automatic operation as required. You are welcome to call the repair facility to gather further information if you require or contact me as well by email or phone at [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);
2021 NEWMAR ESSEX Complaints
This is concerning the brake system (disk rotor & pads) on a vehicle with 2600 miles when detected. Vehicle manufacture date was March 2021, owner possession July 27, 2021. There has not been any one's safety compromised. Front Rotors are experiencing scoring which I can only conclude began during delivery of 2300 miles from Nappanee, IN. to Bend, OR. by manufacture. The abnormal wear was detected at 2600 miles during my post drive safety inspection. The condition was inspected by Josam Truck Frame & Alignment in Orlando Fl. Mileage at inspection was 7700 miles My concern is that this abnormality of scoring taking place with such low mileage and that the condition more than likely began on the delivery drive. Therefore, I can only conclude that there may exist a manufacture defect or improper installation being conducted.;
2021 NEWMAR LONDON AIRE Complaints
The hydraulic steps on this motor home automatically extend and retract when the door is opened or closed. The steps on this unit failed to retract after closing the door, and as I drove away, the steps hit a fence post. They could just as easily hit a person or driving down the road hit another vehicle. There is no warning system on this vehicle to warn the steps did not function as designed, and they are not readily visible from the driver seat. My understanding is that this has happened to others.;