Kia Motors America is recalling certain 2012-2013 Sorento

Dec 02, 2020 — Recall Campaign #20V750000

Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.

The recall was influenced by the Office of Defects Investigation with about 294,756 units affected.

See recall notice

NHTSA Safety Recall Notice

20V750000

Manufacturer:	Kia America, Inc.
Recall date:	December 02, 2020
NHTSA Campaign #:	20V750000
Units affected:	294,756

Description:: Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.
Consequeces:: An engine compartment fire increases the risk of injury.
Corrective action:: Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia dealers will update the Knock Sensor Detection System (KSDS) software, free of charge. The recall began January 27, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC200.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2012 KIA SPORTAGE Complaints
I was driving eastbound in my 2012 Kia Sportage on I-82 just past Benton City MP97 at about 11AM on Monday June 22, 2026, when my engine knocked twice, the red check engine light came on, and I lost power. I pulled over off the road next to a concrete barrier that was beside a rock roadcut. My flashers would not operate, I put it into park, turned off the ignition and immediately noticed the smell of burning oil or rubber. I had 2 half gallon containers of water on my front seat, so I popped the switch, lifted the hood, used the prop rod to hold the hood up as I started dowsing the flames that were popping up on the passenger side of my engine compartment near the firewall. After using both half gallons, I ran to the rear of the vehicle, opened the hatchback, and grabbed a gallon spray bottle of water and brought that back around to the front of the vehicle. By this point the prop rod holding the hood was bending and the flames were popping back up, I pumped the sprayer and directed a stream of water with my left hand and used my right to hold up the hood as the prop rod was not working. After the fire was completely out, I returned to the rear of the vehicle, donned my reflective vest, put a portable flasher on my vehicle, and at this point a Benton County fireman in a pickup arrived - he was called by a motorist that saw me pulling over with smoke trailing my vehicle. The fireman was followed by a large firetruck and crew. They propped up the hood with a bar and inspected the motor to verify the fire was completely extinguished. They took my information and left. A Washington State Patrol arrived, assessed the scene and offered assistance, but I already had called my wife so he left me to wait for her. He told me I had 24 hours to get the car off the interstate. I had the car towed to my driveway by A&E towing at about 2:30PM. I just realized this morning that I ought to report it to you. I haven't tried to start it, but I'm sure it won't.;
2013 KIA OPTIMA HYBRID Complaints
Based on reading some service forms, it seems it may be the hydraulic booster, causing the issue. In order for them to take a look at the brakes system. I was charged a upfront diagnostics fee of $316. While driving warning light comes on " Check brake system " then the car slows down to 10mph immediately. While pressing on the brakes they squeaking, very badly. I have to turn the car off and back on until the flashing " Check brake system" turns off. This happens every 5 to 10 minutes while driving multiple times a day, everyday. This could have caused an accident on multiple occasions. When the warning light comes on, the car immediately goes down to 10mph making it impossible to pullover in time. The car is currently at the dealership for inspection, they're the only ones that i had inspect the car. However reading the Kia forms online alot of other customers are having this same issue. This issue started happening about two months ago. And has progressively gotten worse.;
2013 KIA SORENTO Complaints
The contact owns a 2013 Kia Sorento. The contact stated that there was a knocking sound coming from the vehicle with the engine warning light illuminated. The contact used a diagnostic machine to retrieve DTC: P0136, P0172 system, to the rich bank, and P1326 control module which indicated that the knock sensor needed to be replaced. The vehicle was towed to the local dealer, and the contact was informed that the oil change records were needed. The vehicle was diagnosed, and it was determined that there was too much fuel, and that the knock sensor had failed. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 312,320.;
2015 KIA FORTE Complaints
Recently had oil change . Right after B oil change engine light came on, a solid yellow light car is driving rough it’s a 2015 Kia Forte. Have an appointment Monday 7/13/2026 to have dealer to do a B diagnostic. The same place I had oil change;