Newmar Corporation is recalling certain 2021 Kountry Star and 2017-2021 Dutch Star motorhomes

Feb 17, 2021 — Recall Campaign #21V082000

Newmar Corporation (Newmar) is recalling certain 2021 Kountry Star and 2017-2021 Dutch Star motorhomes. The brake light switch may chafe against the windshield wiper mechanism, which could damage the brake light switch or it's wiring, and cause the brake lights to not illuminate.

The recall was influenced by the manufacturer with about 1,370 units affected.

See recall notice

NHTSA Safety Recall Notice

21V082000

Manufacturer:	Newmar Corporation
Recall date:	February 17, 2021
NHTSA Campaign #:	21V082000
Units affected:	1,370

Description:: Newmar Corporation (Newmar) is recalling certain 2021 Kountry Star and 2017-2021 Dutch Star motorhomes. The brake light switch may chafe against the windshield wiper mechanism, which could damage the brake light switch or it's wiring, and cause the brake lights to not illuminate.
Consequeces:: If the brake lights do not illuminate, other motorists will be unaware of the driver's intention, increasing the risk of a crash.
Corrective action:: Newmar will notify owners, and dealers will inspect the brake light switch and replace it as necessary, free of charge. The recall began on April 12, 2021. Owners may contact Newmar customer service at 1-800-731-8300.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2021 NEWMAR DUTCH STAR Complaints
Last week I had the air dryer filter replaced at Colton Truck Terminal in Colton Ca. Subsequently, I did the complete 7 step air brake system check and discovered that during total loss of air pressure , the emergency brakes would not auto apply. I replaced the dash hand valve and the problem still persists, so I installed the original valve and took the coach back to Colton Truck Terminal to diagnose the problem. Attached is the paper work from Colton Truck Terminal diagnosing the issue and the correction of that issue. Also on that paperwork is the vehicle information. Apparently, two air lines were crossed going into the primary air tank during chassis assembly. Once corrected, the system worked properly. I did not take it to a FL dealer because the chassis is out of warranty and Colton Truck Terminal is a well respected local repair company that almost exclusively works on Class A diesel pusher chassis. My hopes are that FL will reimburse me for this repair that was required as a result of improper initial assembly. My other concern is that there are no other chassis that may have this issue that were built around the same period. Though the emergency brakes could still be manually applied during loss of air pressure, the incorrect assembly prohibited automatic operation as required. You are welcome to call the repair facility to gather further information if you require or contact me as well by email or phone at [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);
2021 NEWMAR KOUNTRY STAR Complaints
The BrakeSync valve is located too close to the turbo charger. In hot weather and slow traffic or high engine load as when climbing long grades enough heat builds up to cause the high pressure hose from the air supply tank to the regulator valve to blow.;