Newmar Corporation is recalling certain 2021 London Aire

Apr 13, 2021 — Recall Campaign #21V258000

Newmar Corporation (Newmar) is recalling certain 2021 London Aire, Dutch Star, New Aire, Ventana, and Mountain Aire vehicles. The steering output shaft may be too short and could disengage from the steering input shaft.

The recall was influenced by the manufacturer with about 19 units affected.

See recall notice

NHTSA Safety Recall Notice

21V258000

Manufacturer:	Newmar Corporation
Recall date:	April 13, 2021
NHTSA Campaign #:	21V258000
Units affected:	19

Description:: Newmar Corporation (Newmar) is recalling certain 2021 London Aire, Dutch Star, New Aire, Ventana, and Mountain Aire vehicles. The steering output shaft may be too short and could disengage from the steering input shaft.
Consequeces:: Disengagement of the steering output shaft may result in a loss of steering, increasing the risk of a crash.
Corrective action:: Newmar will notify owners, and dealers will inspect and, if necessary, replace the steering column, free of charge. The recall began on May 19, 2021. Owners may contact Newmar customer service at 1-800-731-8300 and Shyft Group customer service at 1-800-582-3454. Newmar's number for this recall is 21V-214.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2021 NEWMAR DUTCH STAR Complaints
Last week I had the air dryer filter replaced at Colton Truck Terminal in Colton Ca. Subsequently, I did the complete 7 step air brake system check and discovered that during total loss of air pressure , the emergency brakes would not auto apply. I replaced the dash hand valve and the problem still persists, so I installed the original valve and took the coach back to Colton Truck Terminal to diagnose the problem. Attached is the paper work from Colton Truck Terminal diagnosing the issue and the correction of that issue. Also on that paperwork is the vehicle information. Apparently, two air lines were crossed going into the primary air tank during chassis assembly. Once corrected, the system worked properly. I did not take it to a FL dealer because the chassis is out of warranty and Colton Truck Terminal is a well respected local repair company that almost exclusively works on Class A diesel pusher chassis. My hopes are that FL will reimburse me for this repair that was required as a result of improper initial assembly. My other concern is that there are no other chassis that may have this issue that were built around the same period. Though the emergency brakes could still be manually applied during loss of air pressure, the incorrect assembly prohibited automatic operation as required. You are welcome to call the repair facility to gather further information if you require or contact me as well by email or phone at [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);
2021 NEWMAR LONDON AIRE Complaints
The hydraulic steps on this motor home automatically extend and retract when the door is opened or closed. The steps on this unit failed to retract after closing the door, and as I drove away, the steps hit a fence post. They could just as easily hit a person or driving down the road hit another vehicle. There is no warning system on this vehicle to warn the steps did not function as designed, and they are not readily visible from the driver seat. My understanding is that this has happened to others.;
2021 NEWMAR NEW AIRE Complaints
The contact owns a 2021 Newmar New Aire RV. The contact stated while driving at an undisclosed speed, the instrument cluster failed to function as intended. The contact stated that the instrument cluster was distorted with moving bubbles inside. The contact stated that due to the failure it was difficult to read the screen. The dealer was made aware of the failure. The RV was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 15,000.;
2021 NEWMAR VENTANA Complaints
The Motorhome is equipped with a computer controlled Comfort Drive steering system ( also known as ReAX-C and other names) that is supposed to keep the vehicle going straight at all times with low steering efforts in side winds, pot holes or against the crown of the road. The Comfort Drive is supposed offer consistent steering feel and allow the driver to concentrate on driving with reduced fatigue. This system appears to only be working part of the time - and that is only when driving on a perfectly flat road with little or no wind. On a recent 4,000 mile cross country trip on Interstate highways in this vehicle with crowned roads, pot holes, construction zones and windy conditions it was a literal “white knuckle” fight to maintain steering in my lane. It was very dangerous situation every day never knowing when a gust of wind was going to blow the vehicle off the road or into another lane. I had to fight every minute to try keep this vehicle under control. I had a previous motorhome with a Comfort Drive system that was totally under control at all times. However, I have been told that this current model has a brand new totally redesigned Comfort Drive system. I have been to the Spartan Factory Service in Charlotte, MI on two separate occasions to have this Comfort Drive fixed. The first time they test drove it and said it was fine. The second time they said they used a test machine and it showed “ no faults” so it is fine. They stated they buy the “Comfort Drive” from ZF- TRW and they simply install it per Newmar request. They said it is not of their manufacture and they don’t really know much about it. I also called Newmar to see if they could help, but they say they have nothing to do with the Spartan Chassis, I need to talk to Spartan. It is “not fine”. I feel this is a serious safety situation waiting for a serious accident waiting to happen.;