Newmar Corporation is recalling certain 2017-2022 Dutch Star

May 20, 2021 — Recall Campaign #21V372000

Newmar Corporation (Newmar) is recalling certain 2017-2022 Dutch Star, 2017-2019 Mountain Aire, 2019-2021 Ventana and 2021 New Aire motorhomes. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

The recall was influenced by the manufacturer with about 1,294 units affected.

See recall notice

NHTSA Safety Recall Notice

21V372000

Manufacturer:	Newmar Corporation
Recall date:	May 20, 2021
NHTSA Campaign #:	21V372000
Units affected:	1,294

Description:: Newmar Corporation (Newmar) is recalling certain 2017-2022 Dutch Star, 2017-2019 Mountain Aire, 2019-2021 Ventana and 2021 New Aire motorhomes. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
Consequeces:: A fuel leak in the presence of an ignition source increases the risk of a fire.
Corrective action:: Dealers will inspect the rail threads, and replace the rail as necessary, free of charge. Interim notification letters were mailed to owners on July 16, 2021. Owners may contact Newmar customer service at 1-800-731-8000. Newmar's number for this recall is Cummins 21E-032.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.

Affects the following:

2019 NEWMAR MOUNTAIN AIRE Complaints
My motorhome is currently in a Freighliner shop to replace the 2nd defective DEF head in less than 19,000 miles since New. The defective DEF head causes a derate of power and total shut down and can leave you stranded on the highway or coming down a mountain pass with no power defeating the air compressor therefore no air brakes with a 45 foot, 58,000 GVW vehicle. In my case I was able to get off the highway before total shutdown only because I was aware of the built in shutdown design of the emissions system.;
2021 NEWMAR NEW AIRE Complaints
The contact owns a 2021 Newmar New Aire RV. The contact stated while driving at an undisclosed speed, the instrument cluster failed to function as intended. The contact stated that the instrument cluster was distorted with moving bubbles inside. The contact stated that due to the failure it was difficult to read the screen. The dealer was made aware of the failure. The RV was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 15,000.;
2021 NEWMAR VENTANA Complaints
The Motorhome is equipped with a computer controlled Comfort Drive steering system ( also known as ReAX-C and other names) that is supposed to keep the vehicle going straight at all times with low steering efforts in side winds, pot holes or against the crown of the road. The Comfort Drive is supposed offer consistent steering feel and allow the driver to concentrate on driving with reduced fatigue. This system appears to only be working part of the time - and that is only when driving on a perfectly flat road with little or no wind. On a recent 4,000 mile cross country trip on Interstate highways in this vehicle with crowned roads, pot holes, construction zones and windy conditions it was a literal “white knuckle” fight to maintain steering in my lane. It was very dangerous situation every day never knowing when a gust of wind was going to blow the vehicle off the road or into another lane. I had to fight every minute to try keep this vehicle under control. I had a previous motorhome with a Comfort Drive system that was totally under control at all times. However, I have been told that this current model has a brand new totally redesigned Comfort Drive system. I have been to the Spartan Factory Service in Charlotte, MI on two separate occasions to have this Comfort Drive fixed. The first time they test drove it and said it was fine. The second time they said they used a test machine and it showed “ no faults” so it is fine. They stated they buy the “Comfort Drive” from ZF- TRW and they simply install it per Newmar request. They said it is not of their manufacture and they don’t really know much about it. I also called Newmar to see if they could help, but they say they have nothing to do with the Spartan Chassis, I need to talk to Spartan. It is “not fine”. I feel this is a serious safety situation waiting for a serious accident waiting to happen.;