General Motors, LLC. is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles

Jul 08, 2021 — Recall Campaign #21V517000

General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.

The recall was influenced by the manufacturer with about 28 units affected.

See recall notice

NHTSA Safety Recall Notice

21V517000

Manufacturer:	General Motors, LLC
Recall date:	July 08, 2021
NHTSA Campaign #:	21V517000
Units affected:	28

Description:: General Motors, LLC. (GM) is recalling certain 2022 Chevrolet Bolt EV and Bolt EUV vehicles. One of the two fasteners that secure the driver's frontal air bag to the steering wheel may be missing or improperly tightened.
Consequeces:: An improperly installed air bag may not deploy properly in a crash, increasing the risk of injury.
Corrective action:: Dealers will inspect and replace as necessary, the driver-side air bag fasteners. If the fasteners cannot be tightened properly, the air bag assembly will be replaced. All repairs will be performed free of charge. Owner notification letters were mailed on July 29, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N212340860.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2022 CHEVROLET BOLT EUV Complaints
Car was going into neutral unexpectedly with a message of "two gears selected". Very disorienting as with the one pedal driving mode I was expecting the car to slow and kept moving faster than expected. Luckily nothing happened as I jammed on my breaks. I was reversing towards a hill in my yard that leads to some woods Brought the car to the dealership, and they said the transmission control module failed after 3 years 9 months in service and ~48000 miles. Paid $2000 as it was not covered under warranty;
2022 CHEVROLET BOLT EV Complaints
While driving at a low speed (approx. 5–10 mph), the front passenger-side lower ball joint suffered a catastrophic structural shear without warning. This caused the wheel assembly to collapse outward and the CV axle to pull out of the transmission. The failure caused a complete loss of steering control, veering the vehicle into a curb. Physical evidence (outward axle pull and high-side rim scratches) indicates the mechanical failure preceded the impact. This occurred at only 38,155 miles on a 2022 Chevrolet Bolt EV. Outward Dislocation: Photos show the CV axle pulled OUT of the transmission and the wheel leaning OUT (positive camber). A curb impact would push these components IN. This proves the wheel fell away from the car first. Pre-Impact Grinding: The interior barrel of the rim and the brake dust shield show heavy rotational grinding and metal-on-metal scoring. This confirms the suspension collapsed while the wheel was still spinning at speed, prior to the car coming to a stop. Structural Shear: The lower ball joint stud suffered a complete transverse shear. High-resolution photos of the broken stud face show distinct "beach marks" (concentric rings), which are the physical fingerprint of a slow-growing metal fatigue crack rather than a sudden impact fracture. Rim Damage Profile: Deep gouges are located on the flat face of the wheel spokes rather than the outer lip. This confirms the wheel was already at an extreme tilt (collapsed) when it made contact with the curb. CONCLUSION: The vehicle was maintained and driven under normal conditions. This was a spontaneous, catastrophic structural failure of a safety-critical component. I am requesting that NHTSA investigate this as a potential manufacturing defect for the 2022 Chevrolet Bolt EV.;