Volkswagen Group of America, Inc. is recalling certain 2021 E-Tron Quattro and 2020-2021

Jul 26, 2021 — Recall Campaign #21V569000

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 E-Tron Quattro and 2020-2021 Audi E-Tron Sportback Quattro vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.

The recall was influenced by the manufacturer with about 498 units affected.

See recall notice

NHTSA Safety Recall Notice

21V569000

Manufacturer:	Volkswagen Group of America, Inc.
Recall date:	July 26, 2021
NHTSA Campaign #:	21V569000
Units affected:	498

Description:: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2021 E-Tron Quattro and 2020-2021 Audi E-Tron Sportback Quattro vehicles. An improperly welded rotor and shaft may separate within the integrated brake system.
Consequeces:: Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
Corrective action:: Dealers will replace the brake booster, free of charge. Owner notification letters were mailed September 14, 2021. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 47R1.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2020-2021 AUDI E-TRON

2021 AUDI E-TRON Complaints
I own a 2021 Audi e-tron with approximately 58000 miles. Beginning in March 2026, the vehicle developed intermittent Virtual Cockpit/instrument-cluster problems with blank display. I reported the condition to Audi dealer of Princeton NJ. The vehicle subsequently experienced two dead 12-volt battery incidents and became inoperable. The second 12 volt battery was new. Following the most recent incident, the Audi dealer diagnosed the Virtual Cockpit/instrument cluster as causing a drain on the 12-volt battery and recommended replacement at a cost of approximately $3,500. The replacement part is unavailable, and Audi has provided no estimated delivery date. The vehicle has remained out of service since July 03rd 2026. This condition presents a potential safety concern because failure of the instrument cluster may prevent the driver from reliably viewing speed, warning indicators, vehicle status, range, and other safety-related information. The recurring 12-volt battery discharge may also leave the vehicle unexpectedly disabled. The vehicle is additionally showing an indicated range of only approximately 160 miles at 100% charge. Audi has not established whether this is related to the instrument-cluster failure, high-voltage battery condition, battery-management system, software, or another electrical defect. Audi has not provided documentation of a comprehensive high-voltage battery health and capacity evaluation. Audi issued a recall or service campaign affecting other 2021 Audi vehicles for substantially similar Virtual Cockpit/display problems. However, Audi states that my VIN is excluded and has not provided a technical explanation identifying a different component, part number, software version, supplier, or failure mechanism. I request that NHTSA evaluate whether the recurring instrument-cluster failure and 12-volt battery discharge constitute a broader safety defect and whether the existing Audi recall or service-campaign population should include this car.;