BMW of North America, LLC is recalling certain 2020 M340i

Aug 02, 2021 — Recall Campaign #21V598000

BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.

The recall was influenced by the manufacturer with about 50,024 units affected.

See recall notice

NHTSA Safety Recall Notice

21V598000

Manufacturer:	Toyota Motor Corporation
Recall date:	August 02, 2021
NHTSA Campaign #:	21V598000
Units affected:	50,024

Description:: BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.
Consequeces:: Loss of braking assist can increase the risk of a crash.
Corrective action:: Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2020 BMW 540I Complaints
I am reporting a potential safety concern with my engine. The oil pumps are known to fail due to plastic internal components. BMW has issued a new pump with metal parts, but existing engines are not being helped and if oil pressure drops the car can suddenly stop in traffic, creating a safety hazard.;
2020 BMW M340I Complaints
Oil pump for the 2020 model is made with plastic internals. The passage that controls the flow of oil into your engine is made of plastic. The car didn’t even have 40,000 miles and the plastic broke causing the passage to be in a very close to shut position not allowing enough oil to enter the engine in higher rpm. The mechanic told me this is the biggest thing he is starting to see and he works for BMW Service center of Mamaroneck. He’s seen over 150+ B58TU (engine model) of the year 2020 with broken plastic in the oil pump. For the 2021 model year and up to 2026 they have updated the oil pump to metal internals and metal passageways solving the issue but are not helping us 2020 owners and aren’t taking any responsibility blaming it on owners. The repair cost over 3,000 dollars. I understand if it’s something they can’t figure out but they saw it was their own negligence on using better parts and they switch from plastic to metal oil pumps after they saw an increase of over 2,000+ 2020 bmws with the b58tu in it have this issue. There were no warnings, no lights on the dash, no check engine and no codes on the car or when read with a diagnostic scanner. I even included the difference between the 2020 oil pump (plastic) to the 2021 and up oil pump (metal) which was bought from BMW Parts in Mamaroneck. This is an oem part that they updated on their newer cars and won’t take responsibility for their negligence on their 2020 model.;
2020 BMW X3 Complaints
I am reporting a chronic manufacturing defect on my 2020 BMW X3 that poses an immediate electrical short-circuit and vehicle safety hazard. The passenger-side panoramic sunroof drainage system/roof structure leaks water heavily through the side panel joint of the door frame, directly saturating the front passenger floor carpet. This issue has been ongoing since I received the vehicle in 2020.The vehicle has been brought to Kelly BMW of Columbus, Ohio, at least four separate times since 2020 specifically to address this leak. Technicians have replaced outer seals and cleared tracks, but the leak persists, and on the last visit, unqualified dealership staff claimed they "could not find anything wrong. "This is a severe safety risk: BMW places the primary electronic fuse blocks and vital vehicle wiring harnesses directly underneath the front passenger floorboard carpet. Constant water logging in this exact area threatens to cause sudden, catastrophic electrical failures, component shorts, or vehicle stalling while driving. The manufacturer has failed to issue a recall for this known, widespread G01 platform defect, and dealership service centers lack the training to properly diagnose it.;
2021 BMW X4 Complaints
I am reporting a safety concern regarding BMW vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found on models from 2019 to 2021. The oil pump in these vehicles is failing prematurely. I was told this by service technicians at BMW and confirmed it through my own research. The oil pump failure is due to a plastic adjusting ring breaking. The result is severe oil pressure loss and engine failure. This is uncommon for a vehicle that has 65k miles. The engine failure comes without warning; there are no check engine light warnings. The vehicle's engine just fails I discovered the oil pump failure when I found it unusual that I had to add oil twice over a 6-month period. I took it to the dealer, where they informed me of the issue. This is extremely dangerous, especially when an engine locks up at high speeds on a highway.;