Volvo Car USA, LLC is recalling certain 2021 XC40 BEV vehicles

Nov 12, 2021 — Recall Campaign #21V881000

Volvo Car USA, LLC (Volvo) is recalling certain 2021 XC40 BEV vehicles. A bolt that secures the cross-member bracket for the electrical motor in the engine compartment may be loose or missing.

The recall was influenced by the manufacturer with about 4 units affected.

See recall notice

NHTSA Safety Recall Notice

21V881000

Manufacturer:	Volvo Car USA, LLC
Recall date:	November 12, 2021
NHTSA Campaign #:	21V881000
Units affected:	4

Description:: Volvo Car USA, LLC (Volvo) is recalling certain 2021 XC40 BEV vehicles. A bolt that secures the cross-member bracket for the electrical motor in the engine compartment may be loose or missing.
Consequeces:: A loose or missing bolt may decrease the structural protection of the vehicle, increasing the risk of injury during a crash.
Corrective action:: Dealers will replace the cross-member bracket and install new bracket bolts, free of charge. Owner notification letters were mailed December 16, 2021. Owners may contact Volvo customer service at 1-888-458-1552. Volvo's number for this recall is R10128.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2021 VOLVO XC40

2021 VOLVO XC40 Complaints
I own a 2021 Volvo XC40 Recharge (pure electric). At 49,030 miles, while slowly driving in a parking lot, the vehicle suddenly began shuddering and jerking as if driving over rumble strips. A warning message appeared stating “Propulsion System Failure” and indicated the vehicle would reduce speed. The vehicle lost propulsion and came to a stop. After stopping, the vehicle would not re-enter Drive or Reverse and could not be driven. It was stuck in position in the parking lot but not in a parking space. The instrument cluster and infotainment systems still powered on, but the vehicle repeatedly displayed messages such as “Vehicle system check. Wait” and would not enter a ready-to-drive state. The vehicle had to be towed to the dealership with a dolly. It took 4 hours to move it because the first tow truck could not safely move it with the wheels stuck in place. This failure occurred without prior mechanical warning or other preceding symptoms. Dealer diagnosis identified an internal failure of the front axle inverter high-voltage assembly (IHFA). Service records document a 400A fuse failure, welded battery disconnect unit (BDU) contactor relays (R1 and R2), and overheating/damage to high-voltage battery disconnect components. Repair required replacement of the IHFA, BDU contactors, and high-voltage fuse. The dealership stated this was not a normal wear-and-tear issue. I have since found reports from other Volvo Recharge owners describing similar propulsion failures involving inverter and high-voltage battery disconnect components. My safety concern is the sudden loss of propulsion while the vehicle was in motion, with no warning and complete vehicle immobilization. Had this occurred at highway speed or in traffic, it could have created a serious collision hazard. The dealership service person agreed that my only chance to get the vehicle to a safe location was to coast. After that, it'd be stuck. I was unaware of this, which is itself an issue of concern.;