Keystone RV Company is recalling certain 2021-2022 Raptor and 2021 Montana vehicles equipped

Feb 02, 2022 — Recall Campaign #22V048000

Keystone RV Company (Keystone) is recalling certain 2021-2022 Raptor and 2021 Montana vehicles equipped with certain Sailun tires, size 235/80R16G. Due to a manufacturing issue, the tires may experience a belt separation.

The recall was influenced by the manufacturer with about 92 units affected.

See recall notice

NHTSA Safety Recall Notice

22V048000

Manufacturer:	Keystone RV Company
Recall date:	February 02, 2022
NHTSA Campaign #:	22V048000
Units affected:	92

Description:: Keystone RV Company (Keystone) is recalling certain 2021-2022 Raptor and 2021 Montana vehicles equipped with certain Sailun tires, size 235/80R16G. Due to a manufacturing issue, the tires may experience a belt separation.
Consequeces:: Belt separation could lead to loss of vehicle control, increasing the risk of a crash.
Corrective action:: Dealers will inspect the tire DOT codes, and replace the tires as necessary, free of charge. Owner notification letters were mailed March 2, 2022. Owners may contact Keystone customer service at 1-866-425-4369. Keystone's number for this recall is 22-420.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2021 KEYSTONE MONTANA HIGH COUNTRY Complaints
Hooked camper up to our tow vehicle. Went inside to prepare to leave our storage. Husband turned the propane on and I pressed Further start button on the refrigerator once the pilot light ignited. After less than one minute an error message began beeping on the digital LCD pad to alert that there was a disconnect from the power source being used. Five seconds later it stopped, and the LCD went blank. I shouted to my husband to check the propane because the refrigerator had stopped and he confirmed that it was still running. I hit the start button again several times and nothing occurred. As I turned to go out the door I noticed a faint, small plume of smoke. My husband rushed in and did confirm a slight ozone smell before turning back outside to note smoke from the top vent where the refrigerator lies. He immediately shut the propane off and returned to remove the upper vent while I grabbed the fire extinguisher. As I returned, I immediately noticed flames and smoke from the lower vent. My husband quickly removed that vent cover and extinguish the fire with the extinguisher. Once out, he returned inside to turn off the circuit breakers, followed by unplugging the refrigerator cord from the wall, which is accessible through the lower vent. We thoroughly inspected the entire slide to be assured the fire was completely extinguished. I made a claim to Progressive the next day. We arranged to have a progressive inspector look at the camper at our local RV service center Harler Auto and Glen’s RV service in Romeo Michigan. The assigned inspector, Andy M made his assessment on Friday, XXX and called us the same afternoon to inform us that based on his inspection, it was determined that the damages were due to and confined to a mechanical/electrical failure, and not the result of a sudden, direct, and accidental loss. He was confident that this was due to a manufacturing defect and informed me that there were multiple known recalls on this particular product.;
2022 KEYSTONE RAPTOR Complaints
The contact owns a 2022 Keystone Raptor. The contact received notification of NHTSA Campaign Number: 23V082000 (FUEL SYSTEM, GASOLINE, EQUIPMENT). While inspecting the vehicle, the contact noticed a circular opening had melted on the side of the RV. The local dealer was contacted; however, the dealer refused to perform the recall repair because the RV was not purchased from the dealer. The contact stated that it was a 40-mile drive to the nearest dealer. The manufacturer was notified of the failure and advised the contact that a supervisor would be in contact. The failure mileage was unknown. VIN tool search not available.;