Thor Motor Coach is recalling certain 2020-2021 Omni and Magnitude motorhomes

Feb 18, 2022 — Recall Campaign #22V094000

Thor Motor Coach (TMC) is recalling certain 2020-2021 Omni and Magnitude motorhomes. The LP gas line may have been incorrectly routed through the rear suspension leaf springs, which could damage the line and cause a gas leak.

The recall was influenced by the manufacturer with about 731 units affected.

See recall notice

NHTSA Safety Recall Notice

22V094000

Manufacturer:	Thor Motor Coach
Recall date:	February 18, 2022
NHTSA Campaign #:	22V094000
Units affected:	731

Description:: Thor Motor Coach (TMC) is recalling certain 2020-2021 Omni and Magnitude motorhomes. The LP gas line may have been incorrectly routed through the rear suspension leaf springs, which could damage the line and cause a gas leak.
Consequeces:: A gas leak increases the risk of a fire.
Corrective action:: Dealers will re-route the LP line as needed, free of charge. Owner notification letters were mailed March 24, 2022. Owners may contact TMC customer service at 1-877-798-855-2867. TMC's number for this recall is RC000256. This recall is an expansion of NHTSA recall 21V-754.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2021 THOR MOTOR COACH OMNI Complaints
The front cap above the drivers and passenger compartment come loose from the body. Mine has been to a few dealers and back to Thor's plant. They supposedly fixed it at Thor. But it is coming apart again. After Thor's head management came out and looked at it this last time they told me their is no internal support for the hole front cap. It's held on by self tapping screws where it meets the body of the camper and a few where it meets the truck cap. It is a fiber glass shell that flexes up and down while going down the road. The rear cap is the same way the screws that mount it to the camper are over tightened and fractures the screw heads. Both of these issues are very common on the Omni and Magnitude. The other issue is the suspension the chassis they put it on is to light for some models. Mine being one of the models the bh35. If a 18 wheeler passes you it will almost throw you off the road. Even if the rv is empty. Everyone with one of these. Has to put spring helpers on it to make it not such a handful. The tow hitch on them Is rated at 10,000 lbs and 1,000 lbs of tongue weight. However the ccc of the rv is only 1402lbs meaning if you put a 1,000 lbs tongue weight trailer on it. That only leaves 402 lbs of weight for inside. If you have a driver and passenger in it weighing 200 lbs a piece that leaves 2lbs for your clothes, food, water, bedding ,or anybody you might want to bring with you. The numbers here don't add up to me. And I believe this is a safety problem. Then the electric transfer switch. they put the fresh water tank in the same spot as all the electrical. Including the fuse panel, breaker box for 12v and 220ac power. They have left many wires loose on the transfer switch causing a buzzing noise. This has happened on many rigs. And the water tank leaks on many as well including mine it will flood the floor. Thor supposedly fixed this as well. Mine is still leaking. To me all these issues makes Mine unsafe to use.;