Ford Motor Company is recalling certain 2017-2018 F-Super Duty F-250

Nov 29, 2022 — Recall Campaign #22V880000

Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.

The recall was influenced by the manufacturer with about 18,808 units affected.

See recall notice

NHTSA Safety Recall Notice

22V880000

Manufacturer:	Ford Motor Company
Recall date:	November 29, 2022
NHTSA Campaign #:	22V880000
Units affected:	18,808

Description:: Ford Motor Company (Ford) is recalling certain 2017-2018 F-Super Duty F-250, F-350, and F-450 4x4 vehicles. A radial damper inside the driveshaft may move out of position over time, which can cause a driveshaft imbalance and result in a fracture.
Consequeces:: A fractured driveshaft can cause a loss of drive power. Additionally, a vehicle rollaway could occur while parked if the parking brake is not engaged. Either of these scenarios increases the risk of a crash.
Corrective action:: Dealers will replace the driveshaft, free of charge. Owner notification letters were mailed July 27, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S74.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2018 FORD F-250 SD Complaints
Low fuel pressure alert came on the truck. It went away and then came on again a few days later. We took the truck to Joe Meyers Ford in Houston, TX. They verified the code/alert and replaced the fuel filter, then re-tested. The alert returned and once they continued their diagnosis, it was determined that the fuel pressure control valve had failed, allowing fuel, DEF, and water into the fuel filter. The fuel pressure would no increase to minimum spec of 55 psi. Ford then said that without replacing the Fuel Pressure Control Valve, Fuel pump, fuel filters, and flushing all the lines, the risk for the engine to seize up was very likely. They noted this was a similar issue happening to 2020 and older trucks, but all the same parts and issues. Upon repairing the truck, we have read up on recall 24V957 and feel the issues we encountered are identical in complexity and costs. We paid nearly $20,000 in repairs.;
2018 FORD F-350 SD Complaints
The contact owns a 2018 Ford F-350 SD. The contact stated that after parking the vehicle in the driveway of their residence, the DPF regeneration process activated and completed, and the vehicle was turned off. The contact exited the vehicle. Approximately 15 minutes later, the contact discovered flames coming from under the hood. The fire department responded and extinguished the fire. The cause of the fire was not determined. The dealer and the manufacturer were not notified of the failure. The failure mileage was 150,000.;