BMW of North America, LLC is recalling certain 2022-2024 iX xDrive50 and 2023 i4 eDrive35

Apr 26, 2023 — Recall Campaign #23V295000

BMW of North America, LLC (BMW) is recalling certain 2022-2024 iX xDrive50 and 2023 i4 eDrive35, i4 eDrive40, and i4 M50 Hybrid Electric vehicles. The high voltage battery cell monitoring circuit may have improperly secured electrical connections which can result in an engine stall.

The recall was influenced by the manufacturer with about 31 units affected.

See recall notice

NHTSA Safety Recall Notice

23V295000

Manufacturer:	BMW of North America, LLC
Recall date:	April 26, 2023
NHTSA Campaign #:	23V295000
Units affected:	31

Description:: BMW of North America, LLC (BMW) is recalling certain 2022-2024 iX xDrive50 and 2023 i4 eDrive35, i4 eDrive40, and i4 M50 Hybrid Electric vehicles. The high voltage battery cell monitoring circuit may have improperly secured electrical connections which can result in an engine stall.
Consequeces:: An engine stall increases the risk of a crash.
Corrective action:: Dealers will replace the high voltage battery cell monitoring circuit, free of charge. Owner notification letters were mailed June 22, 2023. Owners may contact BMW customer service at 1-800-525-7417.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2023 BMW I4 Complaints
The steering wheel would suddenly become stiff (frozen or locked) during normal driving especially during turning. When it happened, I lost total control of the car causing dangerous situations on the road. A warning message appeared stating: "Changed steering effort, drive moderately and contact service center." At a BMW dealership, the problem was reproduced and confirmed. They replaced 12 Volt battery, and the car was released. The new 12 volt battery didn't help the steeling issue. After a few weeks, the steeling system completely failed. The car has to be towed to BMW dealership for repair. It was identified that the steeling issue was caused by premature failure of the BMW electronic power steering system.;
2024 BMW IX Complaints
Date and Time: XXX at approximately 3:00 p.m. Pacific Time. Location: Northbound [XXX]. Vehicle: 2024 BMW iX. Occupants: Driver and driver’s son. Weather/Road Conditions: Very hot and Sunny, in the 97-degree temperature; gusting winds at about 17-miles/hr; the vehicle was traveling at normal highway speed. Incident Description: My son and I were returning home from Wine Valley Golf Club, located at [XXX]. I was driving northbound on [XXX] at approximately 60 mph. A large dump truck approached and passed in the opposite southbound lane at an estimated similar speed. As the vehicles passed, the air displacement and wind gust from the dump truck caused my vehicle to shake noticeably. Instantly at the same time, I heard a loud popping sound from the rear upper portion of my vehicle. Looking behind me, I saw that the rear upper exterior body trim had detached and was lying in the roadway. Immediate Response and Safety Actions: I reduced speed, pulled over when it was safe to do so, and stopped the vehicle. After assessing the situation, I safely turned around and traveled southbound toward the location where the trim had detached. I activated the vehicle’s emergency flashers and stopped on the highway shoulder near the debris. I then retrieved the detached trim from the northbound travel lane. No collision occurred, and neither occupant reported an injury. However, entering the roadway to retrieve the part exposed both my son and me to a serious safety risk from passing traffic. Vehicle Damage and Suspected Cause: The rear upper exterior body trim is detached from the vehicle and requires inspection and repair. The trim separated during normal highway operation without contact from another vehicle or object. Because the part detached immediately after wind pressure from a passing dump truck and there was no collision, I am concerned that the failure may be INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);