Tesla, Inc. is recalling certain 2021-2023 Model S and Model X vehicles

Jul 14, 2023 — Recall Campaign #23V488000

Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model S and Model X vehicles. The front-row seat belts may not be connected properly to the pretensioner anchors, which can cause the seat belts to detach.

The recall was influenced by the Office of Defects Investigation with about 15,869 units affected.

See recall notice

NHTSA Safety Recall Notice

23V488000

Manufacturer:	Tesla, Inc.
Recall date:	July 14, 2023
NHTSA Campaign #:	23V488000
Units affected:	15,869

Description:: Tesla, Inc. (Tesla) is recalling certain 2021-2023 Model S and Model X vehicles. The front-row seat belts may not be connected properly to the pretensioner anchors, which can cause the seat belts to detach.
Consequeces:: A detached seat belt may not properly restrain an occupant during a crash, increasing the risk of injury.
Corrective action:: Tesla Service will inspect the front-row seat belts and connect the seat belts to pretensioner anchors, or replace the seat belt assemblies, as necessary, free of charge. Owner notification letters were mailed September 12, 2023. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-20-004.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2023 TESLA MODEL S Complaints
Catastrophic structural failure of the rear driver-side (LH) brake caliper assembly on a 2023 Tesla Model S Plaid at approximately 18,036 miles. While driving normally on a public roadway, the factory-installed rear LH brake caliper bolts backed out completely due to improper assembly torque or a latent material defect. The unbolted caliper detached entirely from its mounting bracket and collapsed into the spinning wheel barrel. The caliper became violently wedged between the wheel rim and the rotor, instantly puncturing the wheel, flattening the driver-side rear tire, damaging the passenger-side (RH) rear tire, and causing an immediate loss of vehicle control. The loose caliper acted as an unconstrained projectile inside the wheel assembly, severing the hydraulic brake line, shredding the electronic parking brake harness, destroying the suspension links (rear lower fore/aft links), and destroying the ABS sensor/module. This failure created an extreme, life-threatening hazard of a sudden high-speed wheel lockup and total brake system failure. An independent Pre-Purchase Inspection (PPI) was completed just 263 miles prior to this incident. The certified inspector completed an 85-mile test drive and verified the braking and suspension systems were operating in normal factory condition with zero abnormal vibrations or loose hardware. This establishes the failure as a sudden, latent assembly torque failure of factory hardware during normal operational stress. The manufacturer's authorized service center confirmed via technician notes that the caliper came entirely loose and lodged into the wheel. Despite this being a severe assembly workmanship failure within the active factory warranty window, the manufacturer is refusing to cover the repair, alleging third-party tampering without physical or forensic proof. The failed hardware is being retained for forensic inspection.;
2023 TESLA MODEL X Complaints
I have a 2018 and a 2023 Tesla both with the same air bag failure warning, specifically Front Passenger Safety Restraint System Issue. Since this is a critical safety component of the car and Tesla appears to have a wide spread problem with this component, please look into this as possible recall situation.;