Tesla, Inc. is recalling certain 2021-2024 Model S and Model X vehicles

Nov 03, 2023 — Recall Campaign #23V743000

Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and Model X vehicles. An incorrect air bag may have been installed when the steering yoke or round steering wheel was replaced with a different style of yoke or steering wheel.

The recall was influenced by the manufacturer with about 194 units affected.

See recall notice

NHTSA Safety Recall Notice

23V743000

Manufacturer:	Tesla, Inc.
Recall date:	November 03, 2023
NHTSA Campaign #:	23V743000
Units affected:	194

Description:: Tesla, Inc. (Tesla) is recalling certain 2021-2024 Model S and Model X vehicles. An incorrect air bag may have been installed when the steering yoke or round steering wheel was replaced with a different style of yoke or steering wheel.
Consequeces:: An air bag that is not designed to function with the replacement steering yoke or wheel may deploy incorrectly, increasing the risk of injury during a crash.
Corrective action:: Tesla Service will inspect and replace the driver air bag as necessary, free of charge. Owner notification letters were mailed January 2, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-20-005.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2024 TESLA MODEL S Complaints
2024 Tesla Model S. Repeated rear tire and rear wheel failures with abnormal wear and possible rear alignment or suspension-related defect. Tesla service history shows repeated rear tire replacements beginning at about 5,165 miles, a later four-wheel alignment, a right rear tire replacement for uneven tire wear under the basic vehicle warranty at about 21,594 miles, a documented bent left rear wheel at about 27,047 miles, a left rear wheel replacement due to crack after a low-pressure/PULL OVER SAFELY alert at about 30,489 miles, and then a right rear tire blowout at about 38,358 miles. In the same March 12, 2026 service record, Tesla also noted inner sidewall damage on the opposite rear tire. Concern is an unresolved recurring rear tire, wheel, alignment, or suspension defect creating blowout risk and unsafe operation. Tesla has replaced tires and wheels but has not identified or corrected the root cause.;
2024 TESLA MODEL X Complaints
On XXX, at approximately 3:30 PM while using FSD (Supervised) on software 2026.21.6, my Tesla Model X came to a sudden complete stop in the middle of a busy four-lane intersection. I had to intervene. The FSD feedback prompt appeared; I selected Critical. Approximately one mile later, while programming a destination, FSD pulled over unsafely on a busy multi-lane road with barely enough room for 50 mph traffic. I intervened again and selected Critical on the prompt. Neither event appears in the Dashcam Viewer (only Sentry parking clips visible). These continue a pattern. Previously, while driving from [XXX] to [XXX], the car jumped across freeway lanes unsafely. I reported it via the Tesla app and to Cathedral City Service. Technicians lacked diagnostic equipment, said they would escalate to the FSD team for research, and promised to realign the front cameras on a return visit. Months later: no follow-up and cameras still cosmetically misaligned. Camera Calibration menu only shows Clear option (I did not clear it). I have submitted a Service request and emailed Tesla requesting internal logs/telemetry and full escalation. Filing this for an independent record. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);