Tesla, Inc. is recalling 2012-2023 Model S, 2016-2023 Model X

Dec 12, 2023 — Recall Campaign #23V838000

Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.

The recall was influenced by the Office of Defects Investigation with about 2,031,220 units affected.

See recall notice

NHTSA Safety Recall Notice

23V838000

Manufacturer:	Tesla, Inc.
Recall date:	December 12, 2023
NHTSA Campaign #:	23V838000
Units affected:	2,031,220

Description:: Tesla, Inc. (Tesla) is recalling 2012-2023 Model S, 2016-2023 Model X, 2017-2023 Model 3, and 2020-2023 Model Y vehicles equipped with all versions of Autosteer leading up to the version(s) that contains the recall remedy. In certain circumstances when Autosteer is engaged, the prominence and scope of the feature's controls may not be sufficient to prevent driver misuse of the SAE Level 2 advanced driver-assistance feature.
Consequeces:: In certain circumstances when Autosteer is engaged, and the driver does not maintain responsibility for vehicle operation and is unprepared to intervene as necessary or fails to recognize when Autosteer is canceled or not engaged, there may be an increased risk of a crash.
Corrective action:: Tesla will release an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 10, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-23-00-008.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

Affects the following:

2023 TESLA MODEL 3 Complaints
Steering becomes very stiff or notchy where you have to pull it out of position or correct it constantly. Doesn't want to return to center! When you stop it returns to normal feeling then as soon as you get up to speed it becomes stiff again.;
2023 TESLA MODEL S Complaints
Catastrophic structural failure of the rear driver-side (LH) brake caliper assembly on a 2023 Tesla Model S Plaid at approximately 18,036 miles. While driving normally on a public roadway, the factory-installed rear LH brake caliper bolts backed out completely due to improper assembly torque or a latent material defect. The unbolted caliper detached entirely from its mounting bracket and collapsed into the spinning wheel barrel. The caliper became violently wedged between the wheel rim and the rotor, instantly puncturing the wheel, flattening the driver-side rear tire, damaging the passenger-side (RH) rear tire, and causing an immediate loss of vehicle control. The loose caliper acted as an unconstrained projectile inside the wheel assembly, severing the hydraulic brake line, shredding the electronic parking brake harness, destroying the suspension links (rear lower fore/aft links), and destroying the ABS sensor/module. This failure created an extreme, life-threatening hazard of a sudden high-speed wheel lockup and total brake system failure. An independent Pre-Purchase Inspection (PPI) was completed just 263 miles prior to this incident. The certified inspector completed an 85-mile test drive and verified the braking and suspension systems were operating in normal factory condition with zero abnormal vibrations or loose hardware. This establishes the failure as a sudden, latent assembly torque failure of factory hardware during normal operational stress. The manufacturer's authorized service center confirmed via technician notes that the caliper came entirely loose and lodged into the wheel. Despite this being a severe assembly workmanship failure within the active factory warranty window, the manufacturer is refusing to cover the repair, alleging third-party tampering without physical or forensic proof. The failed hardware is being retained for forensic inspection.;
2023 TESLA MODEL X Complaints
I have a 2018 and a 2023 Tesla both with the same air bag failure warning, specifically Front Passenger Safety Restraint System Issue. Since this is a critical safety component of the car and Tesla appears to have a wide spread problem with this component, please look into this as possible recall situation.;
2023 TESLA MODEL Y Complaints
Tesla cruise control removed the speed limit functionality as part of its cruise control. I cannot set a maximum speed for the car. Nor can I set a minimum speed for the car. Tesla removed these features through a software update with their autopilot V14. I believe the vehicle is unsafe for myself and others as it does not allow me to set the speed using Traffic-Aware Cruise Control (TACC). Tesla is intentionally removing this feature.;