Ford Motor Company is recalling certain F-250 and F-350 vehicles

May 09, 2025 — Recall Campaign #25V306000

Ford Motor Company (Ford) is recalling certain F-250 and F-350 vehicles. Cracked fuel return line connectors may leak fuel into the engine compartment.

The recall was influenced by the manufacturer with about 5 units affected.

See recall notice

NHTSA Safety Recall Notice

25V306000

Manufacturer:	Ford Motor Company
Recall date:	May 09, 2025
NHTSA Campaign #:	25V306000
Units affected:	5

Description:: Ford Motor Company (Ford) is recalling certain F-250 and F-350 vehicles. Cracked fuel return line connectors may leak fuel into the engine compartment.
Consequeces:: A fuel leak in the presence of an ignition source such as hot engine components, can increase the risk of a fire.
Corrective action:: Dealers will replace the fuel return lines, free of charge. All vehicles have been repaired. Owners may contact Ford Customer Service at 1-866-436-7332. Ford's number for this recall is 25S44.
Notes:: Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 888-327-4236 (TTY 888-275-9171) or go to nhtsa.gov.

Affects the following:

2025 FORD F-250 SD Complaints
For years FORD vehicles, especially pickup trucks, have blinded drivers with their improperly adjusted headlights; because FORD gives incorrect instructions to adjust them. I refer to page 474 of the 2025 Superduty owners manual as evidence. The instructions FORD gives are to set the low-beam LEVEL, shinning the beam onto a vertical surface 25 feet from the vehicle with the beam at the same height as the headlight on the truck. This is incorrect. There should be at least a 3 inch drop of the low-beam at 25 feet. If there is no drop of the tall truck's headlight (the F-250 stock ride height of the headlight is 44 inches above the ground) it will always blind other drivers of cars/sedans--especially via the outside mirrors. This problem has become acute now that the extra bright LED headlights are becoming the norm; making two-lane roads on a rainy night a truly blinding experience. Please require FORD to correct their dangerous mistake.;
2025 FORD F-350 SD Complaints
The driveshaft separated resulting in a loss of motive power while we were driving on the highway at around 65-70mph. We heard/felt vibrations, and a harsh noise then a loud popping noise right before/ during the failure. Then heard dragging as we came toward the guard rail. It caused a loss of control of the vehicle almost causing us to crash. We were able to pull to the side of the road while traffic went around us. One vehicle pulled over in front of us checking their car stating they saw something fly out from under ours but then they left. We looked under and the rear driveshaft was hanging down and the vehicle was unable to drive forward or back. When trying to pull it on a tow vehicle the bearings came out. It is available for inspection. We are waiting for paperwork from a dealer to see all the damages that occurred but they told us the cost was $20,500 to repair. A day before we heard a vibration sound when letting off the accelerator but all the systems checked out and we didn't see anything, that was Saturday. This failure happened on Sunday with no warning systems alerting until after everything happened and the vehicle was no longer able to drive. We just saw there is an active recall and that our vehicle matches date, factory and part damage but our VIN is not included.;