General Motors, LLC is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side

Aug 21, 2025 — Recall Campaign #25V536000

General Motors, LLC (GM) is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.

The recall was influenced by the manufacturer with about 23,656 units affected.

See recall notice

NHTSA Safety Recall Notice

25V536000

Manufacturer:	General Motors, LLC
Recall date:	August 21, 2025
NHTSA Campaign #:	25V536000
Units affected:	23,656

Description:: General Motors, LLC (GM) is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.
Consequeces:: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.
Corrective action:: Dealers will install a shield to divert spilled fuel, free of charge. Owner notification letters were mailed November 14, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252514930.

Affects the following:

2025 CHEVROLET CORVETTE Complaints
The heated seat option burned the seat right thru. It’s a fire hazard because the wiring for the heated seats burned right through the cloth seat. so you have a wire issue under a combustible material like the clothing material in a car seat.;
2026 CHEVROLET CORVETTE CONVERTIBLE E-RAY Complaints
The car will randomly start shuttering and powering down without warning. Every light imaginable on the dash is illuminated along with various pop up warnings on the DIC. When this occurs, the car will not move under its own power and it loses its ability to brake entirely. I was in the middle of an intersection this last time, thankfully a police officer was near and directed traffic around me until i was able to get the car taken to the nearest dealership. This is the third time I've had this happen, I had it looked at and they replaced an electric brake module etc but that clearly didn't work. I've read of a few other similar incidents on various forums. There aren't a lot of these cars produced so far but if there's cases already popping up, something isn't right.;
2026 CHEVROLET CORVETTE COUPE Complaints
I am writing regarding my 2026 Chevrolet Corvette Stingray 1LT and a very serious safety incident that occurred while driving on the Garden State Parkway. While driving at highway speed under normal conditions, my Corvette suddenly jerked and completely shut off without warning. The vehicle immediately lost power and became undrivable. Because there was no emergency shoulder available, I had no safe place to pull over. I was forced to coast for approximately one to two miles at very low speed while surrounded by fast moving traffic. This created an extremely dangerous situation, and I narrowly avoided multiple collisions before I was finally able to reach the side of an exit ramp. After stopping, I exited the vehicle and noticed smoke coming from the engine compartment. When I looked underneath the vehicle, there was a large pool of engine oil leaking onto the ground, and I believe I also saw oil on the side of the engine. The car had to be towed, and I was stranded on the side of the highway for hours. I also had to pay around $750 in towing expenses that I had to pay out of pocket. This incident was especially concerning because the vehicle has had multiple problems since I purchased it. These include a bracket rubbing against other components and causing damage, the air conditioning not functioning properly, and an unusually loud belt noise while driving. I purchased this vehicle brand new with the expectation that it would be reliable and safe. Instead, I have experienced repeated issues, culminating in an incident that placed my safety at high risk. I am requesting that General Motors and the dealership thoroughly investigate this vehicle and provide an appropriate resolution. Given the repeated defects and the severity of this highway failure, I am requesting an exchange for another new Corvette. I have several friends who own 2025 and earlier Corvette models and have not experienced these types of issues, which further reinforces my concerns.;