Rivian Automotive, LLC is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles

Jan 15, 2026 — Recall Campaign #26V009000

Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.

The recall was influenced by the manufacturer with about 869 units affected.

See recall notice

NHTSA Safety Recall Notice

26V009000

Manufacturer:	Rivian Automotive, LLC
Recall date:	January 15, 2026
NHTSA Campaign #:	26V009000
Units affected:	869

Description:: Rivian Automotive, LLC (Rivian) is recalling certain 2022-2025 R1T and 2022-2026 R1S vehicles. The bolts that secure the second-row driver and passenger side seat belt retractor assemblies may be improperly tightened.
Consequeces:: An improperly secured seat belt retractor may not adequately restrain the seat occupant, increasing the risk of injury during a crash.
Corrective action:: Rivian will inspect and tighten the bolts as necessary, free of charge. Owner notification letters were mailed March 2, 2026. Owners may contact Rivian customer service at 1-888-748-4261. Rivian's number for this recall is FSAM-1795.

Affects the following:

2025 RIVIAN R1T Complaints
This vehicle has experienced two separate failures of the high-voltage (HV) battery pack, each resulting in a different drive unit being damaged and total loss of electrical systems while driving. First incident (July 28, 2025): While driving, all warning lights illuminated and the vehicle indicated a possible electrical hazard. The vehicle lost power completely. It was taken to a Rivian service center on July 29, 2025, and was not returned until August 15, 2025 — a total of 17 days out of service. Rivian’s technicians found multiple faults in the HV battery pack and replaced it. Rivian’s own repair notes state that its engineering team requested the front drive unit also be replaced “due to the nature of the failure with the HV battery pack” — i.e., Rivian attributed the drive unit damage to the battery pack failure, not to an independent defect. Both the HV battery pack and front drive unit were replaced under warranty. Second incident (June 29, 2026, approx. 16,256 miles): After charging at a Tesla Supercharger, the vehicle displayed a “Rivian thermal system fault” warning, which indicated driving could continue. While subsequently driving on the highway, the vehicle displayed a “reduced performance” warning, followed by an “all-wheel drive system fault” warning. A loud popping sound was then heard from the rear drive unit, accompanied by visible and smell of smoke in the vehicle. The driver safely pulled over. All electrical systems malfunctioned in the same manner as the first incident. The vehicle is currently undergoing diagnosis; based on the symptoms (identical to the first incident) and Rivian’s own causal link between battery failure and drive unit damage in the first incident, it is possible the HV battery pack is again involved, this time in connection with the rear drive unit.;
2026 RIVIAN R1S Complaints
While I was traveling, I suddenly got a brake light fault, turn signal fault, and front camera fault warning messages that appeared on the computer. Rear driver's side tail light/turn signal light stopped functioning and the rest of the brake lights are stuck on, including the rear third tail light while driving and when vehicle is locked/idle. Rivian had me perform soft and hard resets, but that did not solve these problems. Rivian states they are unable to assist me further until I drive it to a service center located near my home.;