Tesla, Inc. is recalling certain 2026 Model Y and 2024 Model 3 vehicles

Jul 07, 2026 — Recall Campaign #26V445000

Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."

The recall was influenced by the manufacturer with about 15 units affected.

See recall notice

NHTSA Safety Recall Notice

26V445000

Manufacturer:	Tesla, Inc.
Recall date:	July 07, 2026
NHTSA Campaign #:	26V445000
Units affected:	15

Description:: Tesla, Inc. (Tesla) is recalling certain 2026 Model Y and 2024 Model 3 vehicles. The vehicles were originally built for a foreign market and do not have knee air bags, may not be equipped with certain interior safety countermeasures, and may not have been tested for bumper impact resistance procedures. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers, 208, "Occupant Crash Protection," 201, "Occupant Protection in Interior Impact," and Part 581, "Bumper Standards."
Consequeces:: A noncompliant vehicle may have reduced occupant protections, increasing the risk of injury during a crash.
Corrective action:: Tesla will repurchase noncompliant vehicles currently registered in the United States, free of charge. Owner notification letters are expected to be mailed September 5, 2026. Owners may contact Tesla customer service at 1-877-798-3752 or [email protected]. Tesla's number for this recall is SB-26-00-004.

Affects the following:

2024 TESLA MODEL 3 Complaints
BOTH FRONT TIRES ON MY 2024 TESLA MODEL 3 PERFORMANCE DEVELOPED STRUCTURAL BULGES ON THE INBOARD SIDEWALL AT UNDER 19,000 MILES. THE TIRES ARE THE ORIGINAL EQUIPMENT PIRELLI P ZERO 235/35R20 DELIVERED WITH THE VEHICLE ON 12/07/2024. ON 08/05/2026 AT 18,951 MILES, TESLA SERVICE IN DORAL, FLORIDA INSPECTED AND ROAD-TESTED THE VEHICLE FOR A METALLIC RUBBING NOISE THAT INCREASES WITH SPEED AND ALSO OCCURS AT LOW SPEED AT FULL STEERING LOCK UNDER ACCELERATION. TESLA'S OWN REPAIR NOTES ON INVOICE 3000S0017877728 STATE THAT THE NOISE WAS DUPLICATED ON THE ROAD TEST AND APPEARS TO ORIGINATE FROM DEFORMED FRONT TIRES. TESLA TOOK NO ALIGNMENT MEASUREMENT AND THE INVOICE CONTAINS NO CAMBER, CASTER OR TOE READINGS. THE SAME INVOICE RECORDS TIRE PRESSURES OF 40.2, 39.9, 40.6 AND 39.9 PSI, SO UNDERINFLATION IS NOT A FACTOR. THE FAILURES ARE SYMMETRIC: SAME AXLE, SAME INBOARD FACE, BOTH SIDES, AT THE SAME TIME, WHICH IS NOT CONSISTENT WITH ISOLATED INDEPENDENT ROAD HAZARD IMPACTS. THE BULGES ARE ON THE INNER FACE AND ARE NOT VISIBLE DURING A NORMAL WALK-AROUND INSPECTION. TESLA STATES IT PROVIDES NO WARRANTY COVERAGE FOR TIRES AND DECLINED ANY VEHICLE-SIDE DIAGNOSIS. A SIDEWALL BULGE IS A SUDDEN BLOWOUT RISK, AND TWO OF THEM ON THE STEERING AXLE OF A HIGH PERFORMANCE VEHICLE CAPABLE OF HIGHWAY SPEED IS A SAFETY DEFECT CONCERN. OTHER TESLA OWNERS HAVE REPORTED THE SAME INBOARD SIDEWALL BULGE PATTERN AT LOW MILEAGE ON 20-INCH WHEELS, SOME AS EARLY AS 7,000 MILES. I REQUEST THAT NHTSA REVIEW WHETHER FRONT SUSPENSION GEOMETRY OR THE TIRE AND WHEEL PACKAGE ON THIS VEHICLE CONTRIBUTES TO PREMATURE INBOARD SIDEWALL FAILURE. THE VEHICLE REMAINS UNDER ITS 4-YEAR/50,000-MILE BASIC VEHICLE LIMITED WARRANTY.;
2026 TESLA MODEL Y Complaints
Full self driving (FSD) has taken away my ability to set a maximum speed. Car is frequently wrong about the speed limit, especially in constructions zones where the speed limit changes more often. Car goes way too fast, then thinks the speed limit dropped and slows way down and then speeds up again. In addition, the 4 speed profiles they gave us instead of a simple max speed setting are useless. Standard mode usually works best but will sometimes do more than 15 mph over what it thinks the speed limit is.;