DURING A CHANGE IN ASSEMBLY PROCEDURES, CERTAIN OF THE MID-SHIP FUEL TANK STRAPS MAY HAVE BEEN IMPROPERLY

Nov 10, 1980 — Recall Campaign #80V145000

DURING A CHANGE IN ASSEMBLY PROCEDURES, CERTAIN OF THE MID-SHIP FUEL TANK STRAPS MAY HAVE BEEN IMPROPERLY INSTALLED OR MISLOCATED. AS A RESULT, THEY FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN THE EVENT OF A COLLISION, EXCESSIVE FUEL SPILLAGE MAY OCCUR.

The recall was influenced by the manufacturer with about 6,260 units affected.

See recall notice

NHTSA Safety Recall Notice

80V145000

Manufacturer:	Ford Motor Company
Recall date:	November 10, 1980
NHTSA Campaign #:	80V145000
Units affected:	6,260

Description:: DURING A CHANGE IN ASSEMBLY PROCEDURES, CERTAIN OF THE MID-SHIP FUEL TANK STRAPS MAY HAVE BEEN IMPROPERLY INSTALLED OR MISLOCATED. AS A RESULT, THEY FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY". IN THE EVENT OF A COLLISION, EXCESSIVE FUEL SPILLAGE MAY OCCUR.
Consequeces:
Corrective action:: DEALER WILL INSPECT AND, IF NECESSARY, RELOCATE FUEL TANK STRAPS WITHOUT CHARGE TO OWNER.
Notes:: VEHICLE DESCRIPTION: LIGHT TRUCKS.SYSTEM: FUEL; FUEL TANK ATTACHMENTS.CONSEQUENCES OF DEFECT: FUEL SPILLAGE RESULTING FROM AN ACCIDENT COULD CAUSE AVEHICLE FIRE AND PERSONAL INJURY TO PASSENGERS.

Affects the following:

1981 FORD F150 Complaints
I PURCHASED FOUR USED SX 5000 STARFIRE (COOPER) 255/70-15 TIRES FOR MY 1981 FORD F-150 IN MARCH OF 2010. THE TIRES WERE MOUNTED TO WHAT I BELIEVE ARE 15X8 STEEL WHEELS BY THE INDEPENDENT TIRE SHOP THAT I PURCHASED THE TIRES FROM. I THEN DROVE FROM SAINT PETERSBURG, FL TO AUSTIN, TX ON THE TIRES WITH NO PROBLEMS. OVER THE NEXT TWO OR THREE MONTHS, I DROVE ABOUT 500 MILES ON THE TIRES WITH NO ISSUES, UNTIL ONE DAY ONE OF THE FRONT TIRES WAS FLAT IN MY DRIVEWAY, WITH THE TREAD SEPARATED IN ONE AREA. I REPLACED BOTH FRONT WHEELS WITH SPARE WHEELS AND TIRES (UNKNOWN EXACT SPECIFICATIONS, BUT SMALLER), AND WITHIN A COUPLE OF WEEKS, ONE OF THE REAR TIRES (AGAIN, IN MY DRIVEWAY) WAS FLAT, WITH THE TREAD SEPARATED. I PLACED TWO OTHER SPARE WHEELS/TIRES ON THE REAR AND PLACED THE SX 5000S IN MY GARAGE. WITHIN A WEEK, THE TWO SX5000S THAT HAD AIR IN THEM HAD BLOWN, AGAIN WITH THE TREAD SEPARATED. THE FAILURES OCCURRED WHEN THE WEATHER OUTSIDE TURNED HOT (SUMMER). TIRE PRESSURES WERE MAINTAINED NEAR (UNDER) THE MAXIMUM SIDEWALL SPECIFICATIONS, AND THE F-150 WAS NEVER OVERLOADED. THE TRUCK IS PRIMARILY USED FOR FAMILY TRANSPORTATION. I CALLED COOPER AT 1-800-854-6288 BECAUSE RECALL # 147 CLOSELY MATCHED THE PROBLEMS I EXPERIENCED, BUT I WAS TOLD MY TIRES WERE MANUFACTURED IN 2003 AND WERE NOT COVERED BY THE RECALL. THE TIRE INFORMATION IS: DOT 3DM2 B7W3903 C14R. I WAS ADMONISHED BY THE COOPER REPRESENTATIVE ABOUT PURCHASING AND USING USED TIRES, BUT GIVEN THE CIRCUMSTANCES OF ALL FOUR TIRES ESSENTIALLY BLOWING OUT WITH TREAD SEPARATION IN UNEXPECTED FASHION WITHIN A FEW WEEKS (OF SUMMER TEMPERATURES), I FEEL THAT THE UNDERLYING PROBLEM IS THE DESIGN OF THE TIRES, AND NOT THAT THE TIRES WERE ABUSED. UNTIL THE FAILURES, THE AIR PRESSURE IN THE TIRES DID NOT FALL OR RISE EXCEPT DUE TO AIR TEMPERATURES AND DRIVING FORCES, AND THE TREAD LIFE WAS AT LEAST 50%. *TR;
1981 FORD F250 Complaints
TRANSMISSION FAILURE, PARKED VEHICLE IN DRIVEWAY IN PARK, LEFT IDLE POSITION, OPENED THE DOOR, JUMPED OUT OF THE GEAR AND GRABBED AROUND THE VEHICLE AND FLIPPED OUT TRUCK AND THE TRUCK ROLLED BACKWARD, CAUSING FATALITY. *AK;
1981 FORD F350 Complaints
POSSIBLE ENGINE FAILURE RESULTED IN VEHICLE FIRE (OHIO TRAFFIC CRASH REPORT). *MJS;