THE POWER SEAT OR RECLINER WIRING HARNESS CAN BE PINCHED OR CAN CHAFE ON THE SEAT FRAME OR SPRING SUPPORT

Sep 01, 1992 — Recall Campaign #92V124000

THE POWER SEAT OR RECLINER WIRING HARNESS CAN BE PINCHED OR CAN CHAFE ON THE SEAT FRAME OR SPRING SUPPORT ROD, WEARING THROUGH THE WIRE INSULATION AND CAUSING AN ELECTRICAL SHORT.

The recall was influenced by the manufacturer with about 319,181 units affected.

See recall notice

NHTSA Safety Recall Notice

92V124000

Manufacturer:	General Motors, LLC
Recall date:	September 01, 1992
NHTSA Campaign #:	92V124000
Units affected:	319,181

Description:: THE POWER SEAT OR RECLINER WIRING HARNESS CAN BE PINCHED OR CAN CHAFE ON THE SEAT FRAME OR SPRING SUPPORT ROD, WEARING THROUGH THE WIRE INSULATION AND CAUSING AN ELECTRICAL SHORT.
Consequeces:: THE HIGH CURRENT CAUSED BY THE ELECTRICAL SHORT WELDS THECIRCUIT BREAKER ELEMENTS TOGETHER IN THE CLOSED POSITION, LEAVING THE CIRCUITUNPROTECTED AND GENERATING SUFFICIENT HEAT TO BURN THE WIRE INSULATION ANDIGNITE THE SEAT CUSHION MATERIAL.
Corrective action:: REPAIR ANY ABRADED WIRING AND REROUTE THE WIRING HARNESS USING A WIRING HARNESS CLIP.
Notes:: SYSTEM: INTERIOR: SEATING.VEHICLE DESCRIPTION: PASSENGER CARS WITH 6 WAY POWER SEATS OR POWER RECLINERS.

Affects the following:

1990 CHEVROLET CELEBRITY Complaints
TL*THE CONTACT OWNS A 1990 CHEVROLET CELEBRITY. WHILE DRIVING 15 MPH, THE CONTACT WAS UNABLE TO SEE WHICH GEAR HE WAS DRIVING IN AND CRASHED INTO THE REAR OF A VEHICLE. THE VEHICLE WAS INSPECTED BY AN INSURANCE ADJUSTER WHO DETERMINED THAT THE SHIFT INDICATOR WAS UNCLEAR AND WAS THE CAUSE OF THE CRASH. THE VEHICLE IS BEING REPAIRED. THE MANUFACTURER CONFIRMED THAT THERE WERE NO EXISTING RECALLS AND THAT THEY WOULD NOT ASSUME TO REPAIR COST. THE CONTACT IS AWARE OF THE SAFETY RISK SINCE THE SHIFT INDICATION WAS DETERMINED TO BE THE CAUSE OF THE CRASH. THE FAILURE WAS 201,000 UPDATED 9/23/09 *CN THE REPAIR SHOP STATED THE PAINT WAS DULL AND THERE WAS A GLARE FROM THE HIGH GLOSS WINDOW ANGLE. UPDATED 09/28/09. *JB UPDATE 12/14/09 *CN UPDATED 12/16/09*JB;
1990 OLDSMOBILE CIERA Complaints
BEGAN NOTICING STEERING COLUMN WOULD NOT STAY LOCKED INTO DESIRED ANGLE. FURTHER NOTICED ENTIRE WHEEL WOULD HAVE SIDE-TO-SIDE MOVEMENT. AT THIS STAGE IT HAS ABOUT 1-INCH PLAY IN ALL DIRECTIONS, FEEL UNSAFE WHEN STEERING. REPAIR SHOP SAID IT IS COMMON PROBLEM IN THIS CAR; REPAIR INVOLVES REMOVING MOST UPPER COMPONENTS AND TIGHTENING 2 BOLTS AT BASE OF COLUMN AT DASHBOARD. BECAUSE OF COMPLEXITY OF DISASSEMBLY, REPAIR REQUIRES 2 TO 3 HOURS @ $75/HOUR NYC RATES. I FEEL THIS TYPE OF DEFECT SHOULD HAVE SOME RECOURSE THROUGH MANUFACTURER SINCE THIS IS A MAJOR DRIVEABILITY ISSUE WHICH COULD CAUSE SERIOUS ACCIDENT IF NOT CORRECTED.*AK;
1991 BUICK CENTURY Complaints
TL* THE CONTACT OWNS A 1990 BUICK CENTURY (N/A). THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.;
1991 OLDSMOBILE CUTLASS Complaints
TL* THE CONTACT OWNS A 1991 OLDSMOBILE CUTLASS SUPREME. THE CONTACT WAS TRAVELING 50 MPH WHEN THE ACCELERATOR PEDAL WAS DEPRESSED TO THE FLOORBOARD ABNORMALLY. THE BRAKES WERE ENGAGED BUT THE VEHICLE DID NOT RESPOND. THE CONTACT STATED THAT THE VEHICLE ACCELERATED TO 85 MPH BEFORE THE CONTACT TURNED THE VEHICLE OFF. THE CONTACT HAD TO WAIT A FEW MINUTES BEFORE RESTARTING THE VEHICLE AS THE VEHICLE RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT INSPECTED OR REPAIRED FOR THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 200,000.;
1991 PONTIAC 6000 Complaints
WHILE DRIVING VEHICLE STALLED. CONSUMER RESTARTED THE VEHICLE, AND PULLED OVER. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK;