THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE

May 09, 1994 — Recall Campaign #94V087000

THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.

The recall was influenced by the Office of Vehicle Safety Compliance with about 2,255 units affected.

See recall notice

NHTSA Safety Recall Notice

94V087000

Manufacturer:	General Motors, LLC
Recall date:	May 09, 1994
NHTSA Campaign #:	94V087000
Units affected:	2,255

Description:: THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.
Consequeces:: CONSEQUENCE OF NON-COMPLIANCE: OWNERS OF VEHICLE WOULD BE UNAWARE OF THE LOAD CAPACITY OF THE VANS, THE VAN BUILD DATE, AND WOULD NOT HAVE ANY ASSURANCE THAT THE VANS MEET THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS.
Corrective action:: THE LABELS WILL BE FURNISHED TO OWNER'S FOR INSTALLATION ON THE VEHICLES.
Notes:: SYSTEM: EQUIPMENT: CERTIFICATION LABELS.NOTE:PLEASE CONTACT EXPLORER VAN SERVICE CENTER AT 1-800-828-2056. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Affects the following:

1994 CHEVROLET ASTRO Complaints
ON NOVEMBER 21ST, 2011, I WAS DRIVING MY ASTRO VAN ON A STRAIGHT ROAD. THE VEHICLE IN FRONT OF ME APPLIED THEIR BRAKES. I ALSO APPLIED MY BRAKES, BUT MY FOOT SLIPPED OFF THE BRAKE PEDAL. I ATTEMPTED 4 TIMES IN A PANICKED STATE TO TRY AND RE-APPLY MY BRAKES WITH NO SUCCESS. I STRUCK THE VEHICLE IN FRONT OF ME. AFTER CONSIDERING WHAT HAD HAPPENED THAT DAY AND LOOKING AT THE BRAKE PEDAL SIZE IN THE VEHICLE IT IS NO WONDER I COULDN'T READILLY RE-APPLY THE BRAKE. I MEASURED THE BRAKE PEDAL SURFACE AREA. IT IS APPROXIMATELY 4 SQ. INCHES. I HAVE SINCE BEEN LOOKING AT OTHER VEHICLES AND THE SIZE OF THEIR BRAKE PEDAL SURFACE AREA. I HAVE YET TO DATE FOUND SUCH A SMALL BRAKE PEDAL IN ANY OTHER VEHICLE. I HAVE DRIVEN THIS VAN THOUSANDS OF MILES AND KNOW WITHOUT MUCH CONSIDERATION THE PEDALS LOCATION WITHOUT LOOKING, BUT IN A PANICED STATE I FOUND YOU LOOSE THAT REFERENCE AND IT SIMPLY COMES DOWN TO AN INCREASED OR DECREASED CHANCE OF HITTING THAT PEDAL GIVEN SURFACE AREA. *TR;
1994 CHEVROLET G20 Complaints
WHILE DRIVING APPROACHING STOPLIGHT BRAKES WOULD NOT ENGAGE. PRESSED BRAKE PEDAL TO FLOOR AND DRIVE VAN UP AND OVER CURB WHILE USING EMERGENCY BRAKE. CONTACTED DEALER WHERE VAN WAS TOWED. SAID BRAKES NEEDED TO BE BLED AGAIN. BRAKES BLED AND PEDAL STILL FELT THE SAME-SPONGY. TOLD THIS IS NORMAL. DRIVING HOME ON WINDDY ROAD,APPLIED BRAKES NOTHING HAPPEND RELEASED BRAKES AND TRIED AGAIN AND THE FRONT BRAKES LOCKED UP. DEALER SAID TO BRING BACK. THEY INSPECTED SYSTEM SAID BAD MASTER CYLINDER. REPLACED MASTER CYLINDER AND STILL SPONGY BRAKES. DEALER SAID THIS IS NORMAL. THEY STILL DO NOT GRIP AS STRONG DESPITE ALL BRAKE COMPONENTS REPLACED EXCEPT FOR THE VACCUME BOOSTER AND ABS MODULE. I ALSO NO LONGER HEAR THE ABS MODULE COME ON LIKE IT USED TO BEFORE ALL OF THIS, THE ABS LIGHT DOES COME ON AND GOES OUT AFTER STARTING VAN. THE OWNERS MANUAL STATES YOU SHOULD HEAR THE ABS PUMP COME ON WHEN STARTING VAN THEN COME ON AGAIN AT ABOUT 7MPH. IT DOES NOT. TOLD DEALER THIS AND THEY SAID THE MANUAL IS WRONG AND THAT THE BRAKES ARE FINE. YEAH, RIGHT. WHEN GOING 55 MPH DOWN HILL VAN WOULD NOT SLOW DOWN UNLESS I HOLD THE BRAKE PEDAL ALMOST ALL THE WAY DOWN OR USE THE EMERGENCY BRAKE AND COME TO A VERY FAST STOP. AS THIS BEING A FAMILY VAN WE A SCARED TO DRIVE IT. OTHER MECHANICS CAME TO CONCLUSION THE ABS IS AT FAULT. POSSIBLE AIR IN CHAMBERS AND HAS TO BE SERVICED BY DEALER COMPUTER. DEALER SAYS THE ABS IS FINE. WE HAVE ALSO FOUND RECALL ON ABS, BUT OUR VAN IS NOT INCLUDED ACCORDING TO G.M. PLEASE HELP US GET THIS RESOLVED!! THANK YOU *TR;
1994 FORD E-150 Complaints
The contact owns a 1994 Ford E-150. The contact stated that while driving at an undisclosed speed, the contact stated she heard an unusual noise that sounded like something broke. The contact stated she continued to drive and the failure reoccurred. The vehicle was towed to an independent mechanic. The vehicle was diagnosed with a fractured steering box. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 165,000.;
1994 GMC SAFARI (GMC) Complaints
TL*THE CONTACT OWNS A 1994 GMC SAFARI. WHILE DRIVING 20 MPH, THE CONTACT HEARD A LOUD NOISE AND THE FRONT PASSENGER SIDE OF THE VEHICLE FELL TO THE GROUND. THE ROAD CONDITIONS WERE CLEAR. THE VEHICLE WAS TOWED TO A MECHANIC WHO STATED THAT THE FRONT TORSION BAR SNAPPED. THE MECHANIC WAS UNABLE TO REPAIR THE FAILURE BECAUSE THERE WAS A NEW DESIGN FOR THE TORSION BAR. THE CURRENT AND FAILURE MILEAGES WERE 220,000.;
1994 GMC VANDURA G2500 Complaints
TL* THE CONTACT OWNS A 1994 GMC VANDURA G2500 EQUIPPED WITH GOODYEAR WRANGLER TIRES, SIZE: 235/75R15. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED THAT THE SIDEWALL WAS PEELING FROM THREE OF THE FOUR TIRES. THE REAR DRIVER'S TIRE WAS NOT EXPERIENCING THE FAILURE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.;