THESE VEHICLES WERE CONSTRUCTED WITH WELDS IN THE REAR COMPARTMENT PAN ASSEMBLY THAT ARE NOT SUFFICIENT

Jul 01, 1994 — Recall Campaign #94V122000

THESE VEHICLES WERE CONSTRUCTED WITH WELDS IN THE REAR COMPARTMENT PAN ASSEMBLY THAT ARE NOT SUFFICIENT TO COMPLY WITH THE REQUIREMENTS PERTAINING TO FUEL TANK LEAKAGE IN THE EVENT OF A REAR IMPACT COLLISION. THE FUEL TANK ASSEMBLIES DO NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."

The recall was influenced by the manufacturer with about 1,681 units affected.

See recall notice

NHTSA Safety Recall Notice

94V122000

Manufacturer:	General Motors, LLC
Recall date:	July 01, 1994
NHTSA Campaign #:	94V122000
Units affected:	1,681

Description:: THESE VEHICLES WERE CONSTRUCTED WITH WELDS IN THE REAR COMPARTMENT PAN ASSEMBLY THAT ARE NOT SUFFICIENT TO COMPLY WITH THE REQUIREMENTS PERTAINING TO FUEL TANK LEAKAGE IN THE EVENT OF A REAR IMPACT COLLISION. THE FUEL TANK ASSEMBLIES DO NOT COMPLY WITH FMVSS NO. 301, "FUEL SYSTEM INTEGRITY."
Consequeces:: THIS CAN RESULT IN AN INCREASED RISK OF A VEHICLE FIRE IN THE EVENT OF A REAR IMPACT COLLISION.
Corrective action:: DEALER WILL INSTALL RIVETS ADJACENT TO THE LOCATIONS WHERE THE SUSPECT WELDS ARE LOCATED.
Notes:: SYSTEM: FUEL; FUEL TANK ASSEMBLY; FMVSS 301.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT BUICK SERVICE CENTER AT 1-800-521-7300 OR OLDSMOBILE SERVICE CENTER AT 1-800-442-4547 OR PONTIAC SERVICE CENTER AT 1-800-762-2737. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT1-800-424-9393.

Affects the following:

1994 BUICK SKYLARK Complaints
ON 11/14/2012 I BOUGHT AN EXCIDE CAR BATTERY FROM NATIONAL AUTO IN BANGOR, PA. BATTERY RAN FOR ABOUT 2 MOS. THEN STARTED TO GIVE ME PROBLEMS. AFTER SITTING FOR 2 DAYS IT WOULD NOT START. HAD CAR BATTERY JUMPED 3 TIMES. BETWEEN 01/ 2013 AND 02/ 10/2013. BATTERY COMPLETELY DEAD ON 02/11/2013. WAS PUT ON SLOW CHARGE AND RAN FOR ANOTHER 2 DAYS AND DIED AGAIN. TOOK BATTERY BACK TO NATIONAL AUTO ON 02/17/2013. BEFORE TAKING IT THERE I HAD ALTERNATOR, STARTER AND WIRES CHECKED .. EVERYTHING OK.. RETURNED TO STORE. SERVICE PERSON CHECKED IT AND SAID BATTERY WAS CHARGED...TOLD HIM IMPOSSIBLE BECAUSE IT WAS DEAD IN CAR AND WE JUST TOOK IT OUT. HE GAVE ME ANOTHER BATTERY. WORKED FINE UNTIL PALM SUNDAY...DEAD BATTERY...AAA CAME OUT AND JUMPED CAR...WORKED UNTIL 04/04/2013. CALLED CAR STOP ABOUT PROBLEM....GUY SENT OUT.. HE CHECKED BATTERY OUTPUT ONLY 10...NEED 12 VOLTS TO START CAR. ALSO HAD STARTER AND ALTERNATOR CHECKED AGAIN...NO PROBLEMS THERE. TOOK CAR TO SHOP NEXT DAY...NEW BATTERY INSTALLED. CALLED NATIONAL AUTO ABOUT PROBLEM....TOLD TO BRING IT BACK... I DID SO THIS MORNING 04/07/2013 AND WAS TOLD THAT SINCE IT IS HOLDING A CHARGE HE CAN'T GIVE ME MY MONEY BACK...I TOLD HIM " WHAT AM I SUPPOSE TO DO WITH 2 BATTERIES" TOLD ME TO BRING IT BACK WHEN STORE MANAGER IS THERE ON TUES AM OR WED. I AM A 68 YR OLD SENIOR WOMAN...I FEEL LIKE I AM BEING TAKEN ADVANTAGE OF. WHY SHOULD I HAVE TO KEEP GOING BACK...I DO NOT HAVE AN EXTRA HUNDRED DOLLARS TO SPEND JUST TO LET BATTERY SIT IN CELLAR. I WANT MY MONEY BACK. I AM NOT THE FIRST PERSON TO HAVE PROBLEMS WITH THIS BRAND BATTERY. *TR;
1994 OLDSMOBILE ACHIEVA Complaints
TL*THE CONTACT OWNS A 1994 OLDSMOBILE ACHIEVA. THE CONTACT STATED THAT HIS VEHICLE WAS ISSUED RECALL # 00V287000 (ELECTRICAL SYSTEM:STARTER ASSEMBLY) IN 2001. THE RECALL REPAIR WAS NEVER PERFORMED AND THE VEHICLE CAUGHT FIRE. THE VEHICLE'S INTERIOR WAS DESTROYED. THE CONTACT WAS ADVISED TO CALL THE MANUFACTURER. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 138,000.;
1994 PONTIAC GRAND AM Complaints
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