AN INCOMPLETE TIRE SIZE WAS LISTED ON THE CERTIFICATION LABEL

Oct 18, 1994 — Recall Campaign #94V195001

AN INCOMPLETE TIRE SIZE WAS LISTED ON THE CERTIFICATION LABEL. ALSO, THE RIM SIZE LISTED ON THE CERTIFICATION LABEL INCLUDED ONLY THE WIDTH AND NOT THE WIDTH AND DIAMETER AS REQUIRED. THESE VEHICLES DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."

The recall was influenced by the Office of Vehicle Safety Compliance with about 566 units affected.

See recall notice

NHTSA Safety Recall Notice

94V195001

Manufacturer:	IC CORPORATION
Recall date:	October 18, 1994
NHTSA Campaign #:	94V195001
Units affected:	566

Description:: AN INCOMPLETE TIRE SIZE WAS LISTED ON THE CERTIFICATION LABEL. ALSO, THE RIM SIZE LISTED ON THE CERTIFICATION LABEL INCLUDED ONLY THE WIDTH AND NOT THE WIDTH AND DIAMETER AS REQUIRED. THESE VEHICLES DO NOT MEET THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequeces:: CONSEQUENCE OF NON-COMPLIANCE: INCOMLETE CERTIFICATION LABELS CAN RESULT IN INCOREECT TIRES BEING MOUNTED ON THE VEHICLE, AND POSSIBLE INJURY TO PERSONS ATTEMPTING TO MOUNT INCORRECT TIRES.
Corrective action:: NEW CERTIFICATION LABELS WILL BE SENT TO THE OWNERS OF THESE BUSES.
Notes:: SYSTEM: EQUIPMENT; CERTIFICATION LABEL; FMVSS 120.VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES BUILT WITH TIRE SIZES 265/75R 22.5, 295/75R 22.5, OR 275/80R 22.5.NOTE: IF YOU OWN ONE OF THE VEHICLES DESCRIBED ABOVE AND DO NOT RECEIVE A NEW CERTIFICATION LABEL, PLEASE CALL AMTRAN AT 1-800-843-5615. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Affects the following:

1993-1995 AM-TRAN GENESIS

1995 AM-TRAN GENESIS Complaints
OUR SCHOOL DISTRICT HAS FOUR 1995 AMTRAN/INTERNATIONAL BUSES WITH BROKEN ROOF BOW WELDS. (THE SAME TYPE OF PROBLEM AS THE CARPENTER BUSES.) THIS PROBLEM FIRST APPEARED IN THE SPRING OF 2001. THESE DEFECTS WERE BROUGHT TO THE ATTENTION OF INTERNATIONAL, AND THROUGH THE IC BODY DIVISION, INTERNATIONAL SENT UP A REPAIRMAN IN THE SUMMER OF 2001 WHO REPAIRED EACH OF THESE BODIES IN THE FIELD. NOW 2.5 YEARS LATER THESE BODIES ARE COMING APART IN THE IDENTICAL PLACES WHERE THEY WERE REPAIRED. OUR LOCAL INTERNATIONAL DEALER, SKUBIC BROS. INT'L, HAS BEEN TRYING TO WORK WITH INTERNATIONAL DIRECTLY ON THIS ISSUE SINCE WE DISCOVERED IN DECEMBER 2003 THAT THESE REPAIRS DID NOT WORK AND THE WELDS WERE ONCE AGAIN BREAKING. INTERNATIONAL CONTENDS THAT THE BODIES ARE TOO OLD TO BE COVERED UNDER ANY KIND OF WARRANTY, OR EVEN THEIR "FIELD FIX" ANY LONGER. MR. CARL THOMASON AT THE IC PLANT (1-800-993-7686) SAYS THAT THEY HAVE NO RECORDS REGARDING THIS REPAIR. MR. THOMASON DID SAY THAT THE REPAIRS BACK IN 2001 WERE COVERED UNDER A "FIELD FIX" FOR THIS VERY PROBLEM, BUT IT WAS DONE ONLY ON AN "AS NEEDED" BASIS. IN OTHER WORDS, THEY WERE ONLY FIXING THE BODIES THAT CUSTOMERS COMPLAINED ABOUT. THEY APPARENTLY WERE DOING NOTHING WITH THE UNSAFE BODIES THAT CUSTOMERS WERE NOT COMPLAINING ABOUT, OR AWARE OF. WE FEEL THAT THE BODIES WERE NOT PROPERLY REPAIRED BY INTERNATIONAL'S "FIELD FIX" PERSONNEL AND THE LIABILITY AND COST TO PROPERLY REPAIR THESE BUSES SHOULD FALL ON INTERNATIONAL. OUR SCHOOL DISTRICT HAS NOT BEEN ABLE TO USE THESE FOUR BUSES SINCE DECEMBER 2003 AND WE DO NOT HAVE PLANS ON GETTING RID OF THESE BUSES ANYTIME IN THE NEAR FUTURE. I AM AWARE OF A BUS COMPANY IN DULUTH, MN - VOYAGEUR BUS - THAT IS HAVING THE SAME PROBLEMS WITH THEIR 1995 AMTRAN/INTERNATIONAL BUSES. THEY WERE ALSO PART OF THE "FIELD FIX" BACK IN 2001.;