WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE

Apr 22, 1996 — Recall Campaign #96V070000

WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

The recall was influenced by the manufacturer with about 73,500 units affected.

See recall notice

NHTSA Safety Recall Notice

96V070000

Manufacturer:	Ford Motor Company
Recall date:	April 22, 1996
NHTSA Campaign #:	96V070000
Units affected:	73,500

Description:: WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequeces:: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Corrective action:: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Notes:: VEHICLE DESCRIPTION: PASSENGER, MULTI-PURPOSE VEHICLES AND MINI-VANS.NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Affects the following:

1996 FORD AEROSTAR Complaints
CONDENSED VERSION: @ 70MPH POSTED SPEED LIMIT GOODYEAR ALLEGRA TOURING TIRE EXPLODED LIKE A 1/4 STICK OF DYNAMITE AND ALMOST COST ME MY LIFE IF MY REACTIONARY TIME HAD BEEN ANY SLOWER. 3 OTHER TIRES SAME LEAKING THROUGH SIDEWALL GOODYEAR DECORATIVE GILLS ON SAME THIS HAS NOT RESOLVED. SELLER HAS NOT RESOLVED AND REFUSES THOUGH GOODYEAR SAID TO REPLACE BEFORE THE MAIN ISSUE OF THE LEFT FRONT DRIVER TIRE EXPLODING AT 70 MPH, . LITIGATION IS NEXT STEP IF AMICABLE RESOLUTION CAN NOT BE HAD. CONTACT HAS BEEN EXTENSIVE WITH GOODYEAR TO NO RESULTS.;
1996 FORD CROWN VICTORIA Complaints
TL* THE CONTACT OWNS A 1996 FORD CROWN VICTORIA. THE CONTACT STATED THAT WHILE MAKING A LEFT TURN OFF A DRIVEWAY ONTO A LOT, THERE WAS A LOUD METAL BRAKING NOISE COMING FROM THE FRONT DRIVER SIDE OF THE VEHICLE. THE CONTACT STATED THAT THE FRONT DRIVER SIDE COLLAPSED TO THE GROUND. THE CONTACT NOTICED THE LOWER BALL JOINT DETACHED. THE VEHICLE WAS TOWED TO A PRIVATE INDEPENDENT PARKING LOT WHERE THE CONTACT WAS TO INSPECT THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 136,000. *BF CONSUMER STATED FAULTY RUBBER SEAL WAS DUE TO CORROSION AND MAY HAVE ANOTHER ONE WITH SAME PROBLEM.*JB *BF;
1996 FORD EXPLORER Complaints
WHILE STATIONARY AND PREPARING TO SAFELY OPERATE THE VEHICLE, THE DRIVER'S SIDE SEAT BELT RECEPTACLE DOES NOT RETAIN THE SEAT BELT. IT MAY HOLD FOR A BRIEF MOMENT, BUT THEN RELEASES THE BELT RENDERING THE SEAT BELT SYSTEM INEFFECTIVE AND UNSAFE.;
1996 FORD THUNDERBIRD Complaints
WHEN DRIVING THE AIR BAG LIGHT BEGAN BLINKING THE HORN AND CRUISE CONTROL SWITCHESYSTEM STOPPED WORKING IN MOTION FAILURE OF THE CLOCK SPRING;
1996 LINCOLN TOWN CAR Complaints
The contact owns a 1996 Lincoln Town Car. The contact stated while the vehicle was turned on and he was shifting the vehicle from park(P) to drive(D), with his foot on the brake pedal, the vehicle lunged forward at high speed. The contact stated that the acceleration was extreme. The contact observed smoke coming from the rear tires as the vehicle accelerated. The contact was able to safely stop the vehicle after approximately 50 feet but had to depress the brake pedal with force. The contact stated no warning light was illuminated. The contact stated that the vehicle was not turned off but was shifted to park(P). The contact had tested and shifted the vehicle from park (P), drive (D), neutral (N) and reverse (R) and the vehicle reacted normally to each gear change. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 140,000. The contact stated that the vehicle was sold to the mechanic who repaired it.;