THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT

Apr 25, 1996 — Recall Campaign #96V071000

THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.

The recall was influenced by the Office of Defects Investigation with about 7,900,000 units affected.

NHTSA Safety Recall Notice

96V071000

Manufacturer:	Ford Motor Company
Recall date:	April 25, 1996
NHTSA Campaign #:	96V071000
Units affected:	7,900,000

Description:: THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
Consequeces:: THIS CONDITION COULD CAUSE OVERHEATING, SMOKE, AND POSSIBLY FIRE IN THE STEERING COLUMN AREA OF THE VEHICLE.
Corrective action:: DEALERS WILL REPLACE THE IGNITION SWITCH.
Notes:: SYSTEM: ELECTRICAL; IGNITION SWITCH. VEHICLE DESCRIPTION: PASSENGER AND MULTI-PURPOSE VEHICLES AND LIGHT DUTY TRUCKS. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Affects the following:

1988 FORD EXP Complaints
THE BRAKES FAIL APPROXIMATELY EVERY SIX TO SEVEN MONTHS, EVEN AFTER REPLACING PADS, CALIPERS, ROTORS, AND A NEW MASTER CYLINDER AND METERING VALVE.;
1989 FORD CROWN VICTORIA Complaints
WHILE MY MECHANIC WORKED ON MY CAR, I BORROWED HIS 1989 CROWN VICTORIA. ON THE THIRD DAY I HAD IT, WHILE DRIVING IN A 45 MPH ZONE, THE GAS PEDAL SUDDENLY PULLED AWAY FROM MY FOOT AND WENT ALL THE WAY TO THE FLOOR. I WAS NOT USING CRUISE CONTROL SO I TRIED PULLING THE PEDAL UP BY PLACING MY FOOT UNDER IT AND PULLING UP. THAT DIDN'T WORK SO I HIT THE GAS PEDAL A FEW TIMES, BELIEVING IT WAS STUCK SOMEHOW. WHEN THAT DIDN'T WORK I HIT THE BRAKES TO PULL THE CAR OVER. THE CAR WAS QUICKLY GAINING SPEED AS I DID ALL OF THESE THINGS AND HITTING THE BRAKES DIDN'T DO ANYTHING AT ALL. THEN I STOOD ON THE BRAKES WITH BOTH FEET WHILE THE CAR WAS UP TO 80 MPH. STANDING ON THE BRAKES WITH BOTH FEET ONLY BROUGHT IT DOWN TO 60 MPH. I THEN MANAGED TO GET THE CAR INTO NEUTRAL GEAR AND PULL IT OVER ON THE SHOULDER BY ALSO USING THE BRAKES, BUT IT WAS REVVING HIGH AND BLACK SMOKE WAS NOW COMING FROM UNDER THE HOOD. I GOT OUT OF THE CAR AND RAN DOWN THE ROAD AWAY FROM THE CAR, WHEN THE CAR STARTED SPARKING UNDERNEATH, THEN IT BROKE INTO FLAMES. THE WHOLE FRONT OF THE CAR WAS ENGULFED IN FLAMES AND 2 TIRES EXPLODED BEFORE THE FIRE COMPANY ARRIVED. *JB;
1989 LINCOLN TOWN CAR Complaints
LETTER ON BEHALF OF CONCERN ABOUT THE 1996 RECALL ON LINCOLN TOWN CARS, HIS BROTHER-IN-LAW IS HAVING ELECTRICAL PROBLEM WITH THE IGNITION SWITCH ON HIS 1989 LINCOLN TOWN CAR; SEND INCOMING LTR WITH REPLY TO ATTN: ALLISON JACKSON/FOLEY *TGW THE CONSUMER STATED THE KEY DID NOT OPERATE PROPERLY. THE CONSUMER LEARNED A RECALL HAD BEEN ISSUED FOR THE PROBLEM, BUT THE PREVIOUS OWNERS WERE NOT AWARE OF THE PROBLEM WHEN THEY SOLD THE VEHICLE TO THE CONSUMERS BROTHER-IN-LAW. *JB;
1989 MERCURY GRAND MARQUIS Complaints
WHILE DRIVING AT APPROXIMATELY 25 MILES PER HOUR IN PERFECT WEATHER, MY W/W MICHELIN XZ4 215/70/15M/S BLEW OUT ON MY GRAND MARQUIS FROM THE CENTER/TOP OF THE TIRE(NOT SIDEWALL). THERE WERE NO ROAD HAZARDS. THE TIRE HAS A LARGE GASH, AND EXTENSIVELY SPLAYED STEEL BELTS EXPOSED/TORN. LUCKILY I WAS ONLY A BLOCK FROM HOME AND WAS ABLE TO GET HOME TO CHANGE IT. I'VE NEVER SEEN EXTENSIVE TIRE DAMAGE LIKE THIS BEFORE AND AM CONCERNED B/C ALL THE TIRES ON THE CAR ARE THE SAME MAKE AND MODEL. IS THERE A DEFECT IN THE MICHELIN XZ4 SERIES?*JB;
1990 FORD ESCORT Complaints
WHILE TRAVELING ON A FREEWAY AT THE SPEED LIMIT OF 65 MILES PER HOUR, I ENDED UP IN A SKID ON DRY PAVEMENT. I DON'T REMEMBER HOW I GOT INTO THE SKID DUE TO HEAD INJURIES RECEIVED IN THE RESULTING ACCIDENT. THE CAR SKIDDED SIDEWAYS FOR QUITE A WAYS AND DID NOT RESPOND NORMALLY TO ATTEMPTS TO STEER IT. PERHAPS THE ENGINE STALLED AND THE POWER STEERING WAS NO LONGER WORKING. THE CAR EVENTUALLY HIT THE RAISED CONCRETE RUMBLE STRIPS WHILE SKIDDING SIDEWAYS. THE CAR THEN FLIPPED OVER IN THE AIR AND TUMBLED DOWN THE MEDIAN, WITH THE FIRST IMPACT LIKELY TO THE DRIVER'S SIDE ROOF, KNOCKING OUT THE DRIVER. THE CAR CONTINUED TO TUMBLE DOWN THE MEDIAN UNTIL THE CAR VAULTED AND LANDED ON ITS TOP. I REMEMBER BEING UPSIDE DOWN IN THE AIR, BUT NOTHING ELSE UNTIL I CAME TO HANGING UPSIDE DOWN FROM MY SEAT BELT WITH BLURRED VISION. I HAD 2 LARGE LUMPS ON THE TOP OF THE HEAD, A BADLY SWOLLEN JAW AND GUMS, A SWOLLEN TONGUE (BITTEN ON BOTH SIDES), ONE NOSTRIL FILLED WITH BLOOD, THE BACK OF MY HEAD NECK AND SHOULDERS WERE SWOLLEN BY WHAT FELT LIKE ABOUT 1/4 TO 1/2 INCH THICK. I HAD BRUISES AROUND MY RIGHT ELBOW, ON MY RIGHT THIGH, AND LIKELY OTHER PLACES, AS WELL AS A COMPRESSION FRACTURE OF THE SECOND LUMBAR VERTEBRA FROM THE BOTTOM (L4?). SINCE I HAD DIFFICULTY BREATHING, THEY DID A TRACHEOTOMY ON ME WHILE WAITING FOR THE AMBULANCE. THEY PRIED OPEN THE REAR HATCH TO GET ME OUT OF THE VEHICLE. I WAS IN THE HOSPITAL 5 DAYS, OUT OF WORK 5 WEEKS, AND IN VARIOUS DEGREES OF PAIN FOR ABOUT 1 YEAR. THE ROOF FAILED TO PROTECT ME, THE INERTIA LOCK SHOULDER HARNESS FAILED TO PREVENT MY CHIN FROM HITTING THE STEERING WHEEL AND ITS FAILURE TO WORK LIKELY RESULTED IN THE COMPRESSION FRACTURE WHICH THE DOCTOR SAID WAS PROBABLY FROM LUNGING FORWARD. THE ONLY THING THAT KEPT ME IN THE CAR WAS THE MANUAL ADJUSTED LAP BELT, WHICH IS NO LONGER INSTALLED IN FORDS. ALL BELTS ARE INERTIA LOCK, LIKE THE SHOULDER BELT OF THIS CAR WAS. THE VEHICLE HAD A MANUAL TRANSMISSION. *TR;