VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY

Mar 12, 1999 — Recall Campaign #99V045000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.

The recall was influenced by the Office of Defects Investigation with about 138,691 units affected.

See recall notice

NHTSA Safety Recall Notice

99V045000

Manufacturer:	General Motors, LLC
Recall date:	March 12, 1999
NHTSA Campaign #:	99V045000
Units affected:	138,691

Description:: VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME FRONT SEAT BACK RECLINER GEAR TEETH MAY WEAR EXCESSIVELY THROUGH REPEATED USE, AND COULD CAUSE THE SEAT BACK TO SLIP PARTIALLY REARWARD WHEN FORCE IS APPLIED.
Consequeces:: IF THIS HAPPENS WHILE THE VEHICLE IS BEING DRIVEN, IT COULD CAUSE A LOSS OF CONTROL, INCREASING THE RISK OF A CRASH.
Corrective action:: DEALERS WILL REPLACE THE FRONT SEAT RECLINER MECHANISMS.
Notes:: OWNER NOTIFICATION BEGAN MARCH 13, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SATURN AT 1-800-553-6000, PROMPT 3.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

1995 SATURN SC Complaints
WE HAVE HAD NO ACCIDENTS AS OF NOW, BUT THE FRONT SEATBELTS WILL NOT LOCK WHEN BRAKING HARD. *TR;
1995 SATURN SC1 Complaints
MY CAR SOMETIMES SHIFTS OUT OF GEAR(AUTOMATIC) AND THEN THE "SERVICE ENGINE LIGHT" COMES ON. WHEN PUT IN REVERSE, PAUSES FOR A COUPLE SECONDS THEN BANGS INTO GEAR. THIS CAR HAS AN INTERMITTENT PROBLEM WITH THE TRANS WHICH LEADS ME TO THINK THAT THE TRANS IS GOOD BUT A SENSOR IS BAD. I HAVE SPOKEN TO SEVERAL PEOPLE WITH THE SAME PROBLEM. *JB;
1995 SATURN SL Complaints
AUTO ACCIDENT THAT OCCURRED ON 07/31/2015, THE LEFT FRONT AIR BAG DEPLOYED ON ITS OWN CAUSING INJURIES TO THE PASSENGER IN OUR VEHICLE. THE VEHICLE WAS STATIONARY AND ONCE THE KEYS WERE TAKEN OUT IS WHEN RIGHT FRONT AIR BAG WAS DISPLOYED.;
1995 SATURN SW Complaints
SOHC LK0/L24 (FROM HTTP://EN.WIKIPEDIA.ORG/WIKI/SATURN_I4_ENGINE#SOHC_LK0.2FL24) THE SOHC (LK0/L24) CYLINDER HEAD HAD 8 VALVES AND WAS MADE OF LOST FOAM CAST ALUMINUM. THE CAMSHAFT WAS LOCATED IN THE CENTER OF THE CYLINDER HEAD AND DRIVEN BY A CHAIN OFF THE FRONT CRANKSHAFT SPROCKET. MOTION FROM THE CAMSHAFT WAS TRANSMITTED TO THE EIGHT VALVES BY THE HYDRAULIC LIFTERS AND ROCKER ARMS. THE LK0 ENGINE FIRST USED TBI (THROTTLE BODY INJECTION) FOR FUEL DELIVERY AND WAS RATED AT 85 HP (63 KW) AND 110 FTLBF (149 NM) OF TORQUE FROM 1991 TO 1994. THE L24 ENGINE RECEIVED MPFI (MULTI-PORT FUEL INJECTION) IN 1995 WHICH INCREASED POWER OUTPUT TO 100 HP (75 KW) AND 114 FTLBF (155 NM). THIS ENGINE WAS USED FROM 1995 TO 2002. THE SOHC ENGINE WAS AVAILABLE ON THE BASE MODEL S-SERIES VEHICLES (SC1, SL, SL1, SW, SW1) 1992 THROUGH 1998 L24 CYLINDER HEADS DEVELOPED ISSUES WITH CRACKS DEVELOPING IN THE FIFTH CAMSHAFT JOURNAL, LOCATED CLOSEST TO #4 CYLINDER. THE HAIRLINE CRACK WOULD DEVELOP BETWEEN THE OIL FEED PORT OF THAT JOURNAL AND THE COOLANT PASSAGES IN THE CYLINDER HEAD. SYMPTOMS WOULD RANGE FROM OVERHEATING TO LOW COOLANT, HOWEVER, MOST CARS AFFECTED BY THIS ISSUE EXHIBITED OIL MIGRATION INTO THE COOLING SYSTEM. THE RESULTING MIXTURE OF THE TWO FLUIDS WOULD RESULT IN A THICK BROWN "MILKSHAKE"-LIKE MIXTURE, VISIBLE IN THE COOLANT OVERFLOW TANK. SATURN RELEASED UNADVERTISED POLICY WHICH WOULD COVER THIS ISSUE, EXTENDING THE WARRANTY ON THE CYLINDER HEAD TO 6 YEARS OR 100,000 MILES (160K KM). REPAIR REQUIRED THE REPLACEMENT OF THE CYLINDER HEAD. AND FLUSHING OF THE COOLANT SYSTEM. BADLY AFFECTED CARS WOULD SEE COOLANT IN THE OIL, AS WELL AS OIL IN THE COOLANT, AND WOULD REQUIRE THE REPLACEMENT OF THE COMPLETE ENGINE ASSEMBLY. UNTIL THE CYLINDER HEAD CASTING WAS REDESIGNED ... *TR;