VEHICLE DESCRIPTION: 40' STANDARD FLOOR TRANSIT BUSES. FAILURE OF A SOFT SEAT CHECK VALVE IN WHEELCHAIR

Apr 24, 2000 — Recall Campaign #99V242004

VEHICLE DESCRIPTION: 40' STANDARD FLOOR TRANSIT BUSES. FAILURE OF A SOFT SEAT CHECK VALVE IN WHEELCHAIR LIFTS PROVIDED BY LIFT-U, MAY ALLOW THE FRONT AND REAR PLATFORM BARRIERS TO RETURN TO A HORIZONTAL POSITION FROM THE VERTICAL POSITION THEY ARE SUPPOSED TO BE LOCKED IN.

The recall was influenced by the Office of Defects Investigation with about 130 units affected.

See recall notice

NHTSA Safety Recall Notice

99V242004

Manufacturer:	NABI Bus, LLC
Recall date:	April 24, 2000
NHTSA Campaign #:	99V242004
Units affected:	130

Description:: VEHICLE DESCRIPTION: 40' STANDARD FLOOR TRANSIT BUSES. FAILURE OF A SOFT SEAT CHECK VALVE IN WHEELCHAIR LIFTS PROVIDED BY LIFT-U, MAY ALLOW THE FRONT AND REAR PLATFORM BARRIERS TO RETURN TO A HORIZONTAL POSITION FROM THE VERTICAL POSITION THEY ARE SUPPOSED TO BE LOCKED IN.
Consequeces:: THIS COULD ALLOW A MOBILITY AID TO ROLL OFF OF THE LIFT PLATFORM INJURING ITS OCCUPANT. LIFT-U WILL REPLACE THE SOFT SEAT CHECK VALVES.
Corrective action:: LIFT-U WILL REPLACE THE SOFT SEAT CHECK VALVES.
Notes:: NABI RECALL NO. 20001.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT LIFT-U AT 1-209-838-2400 OR NABI AT 1-256-831-4296. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

1998-1999 NABI TRANSIT BUS

1999 NABI TRANSIT BUS Complaints
I AM WRITING TO YOU ABOUT THE MARYLAND MTA BUSES. I WORK FOR THEM AND RECENTLY A PRACTRICE OF ABANDONING AND DISABLING THE FIRE SUPPRESION SYSTEM ON THEM. ON A GREAT PART OF OUR FLEET WHERE THERE HAS BEEN A PROBLEM WITH THIS SYSTEM OR IT HAS GONE OFF AS ARESULT OF A FIRE THEM SYSTEM HAS NOT BEEN RECARGED AND PUT BACK INTO USE. WE HAVE BEEN FORCED TO BYPASS SHUT-DOWN SYSTEMS SO THE BUS CAN BE SENT BACK OUT. WHEN CHALLENGED OUR JOBS ARE THREATENED. RECENTLY WE HAD A TURBO BLOW, RESULTING IN A FIRE IN THE ENGINE COMPARTMENT OF A BUS. BECAUSE THE SYSTEM WAS INOPERATIVE THE VEHICLE SUSTAINED SEVERE DAMAGE AND THE DRIVER WAS TAKEN TO THE HOSPITAL FOR TREATMENT OF SMOKE INHALATION. THERE WERE 9 PASSENGERS ON BOARD ALSO, LUCKILY THEM GOT OFF WITHOUT INJURY. NOW THAT THEY HAVE DODGED A BULLET, THEY ARE TRYING TO COVER UP THIS PROBLEM, BY FIXNG SYSTEMS. WE STILL BUSES THAT ARE RUNNING AROUND THE STREETS OF BALTIMORE WITHOUT THIS PROTECTION. THIS IS ONLY A BANDAID OVER THE PROBLEM. BECAUSE OF THE ILLMANAGEMENT OF THIS SYSTEM THIS PROBLEM WILL OCCUR AGAIN. THE OCCURANCE I SPOKE OF HAPPENED ON AWEEKEND WHEN FEWER PEOPLE RIDE THE BUS HAD THIS HAPPENED DURING THE REGULAR WEEKDAY COMMUTE ON THIS BUS ROUTE THERE WOULD HAVE BEEN MORE INJURIES AS WELL AS POSSIBLE DEATHS. SOMEONE NEEDS TO INVESTIGATE THIS AND OTHER PRACTICES SUCH AS SENDING BUSES OUT WITH BAD BRAKES ON WHAT THEY CALL SHORT TRIPPERS JUST TO MAKE THEMSEVLES LOOK GOOD. ANY HELP WOULD BE APPRECIATED. YOUR FORM DOESN'T HAVE ANY PLACE FOR A LOCATION ON INCIDENT SO HERE IS WHERE IT HAPPENED 1 BLOCK WEST OF 702 & OLD EASTERN AVE. IN ESSEX MD. BALTO. COUNTY. *AK;