VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE

Sep 20, 1999 — Recall Campaign #99V250000

VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.

The recall was influenced by the manufacturer with about 25,306 units affected.

See recall notice

NHTSA Safety Recall Notice

99V250000

Manufacturer:	Ford Motor Company
Recall date:	September 20, 1999
NHTSA Campaign #:	99V250000
Units affected:	25,306

Description:: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequeces:: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Corrective action:: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
Notes:: FORD RECALLNO. 99S26. OWNER NOTIFICATION BEGAN OCTOBER 11, 1999. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

1999 FORD TAURUS Complaints
THE HEADLIGHTS HAVE HAD CONDENSATION INSIDE FOR SEVERAL MONTHS. WITH TORRENTIAL RAINS TWO WEEKS AGO, THE PASSENGER SIDE HEADLIGHT TOOK ON AN INCH AND A HALF OF WATER INSIDE THE COVER, AND THE DRIVER SIDE HAD INCREASED CONDENSATION TO OBSCURE THE WHOLE COVER. THE CAR IS COMMONLY PARKED OUTSIDE MY APARTMENT (URBAN AREA) WHEN NOT IN USE. DATES ARE APPROXIMATE, AND I'VE PUT THE CAR IN THE AAA SHOP TO GET THE HEADLIGHTS REPLACED (BIG EXPENSE, AS THE CAR'S OLD ENOUGH TO VOTE!);
1999 MERCURY SABLE Complaints
I BOUGHT A USED 1999 MERCURY SABLE GS WITH THE U TYPE 3.0L V6 ENGINE 2 MONTHS AGO. JUST RECENTLY I NOTICED THE CAR WANTING TO LUNGE FORWARD WHILE HOLDING THE BRAKE AT STOPS. THEN A FEW DAYS LATER WHENEVER I START THE CAR IT LUNGES FORWARD. NOTHING DRAMATIC BUT DEFINITELY NOTICEABLE. I STARTED LOOKING ONLINE TO SEE ABOUT A RECALL AND 1 WAS PRESENT A LONG TIME AGO. IS IT TO LATE TO GET MY CAR CHECKED OR HOW TO SEE IF IT WAS EVER SERVICED OR CALLED FOR THE RECALL.;
2000 FORD MUSTANG Complaints
The contact owns a 1965 Ford Mustang. The contact stated that upon starting the vehicle, the vehicle unintendedly reversed on an incline of a parking lot and struck another parked unoccupied vehicle. There was no injury sustained. The contact stated that the vehicle was not designed with air bags. The vehicle sustained fenders, bumpers, and paint damage. The contact was able to drive to the residence. The vehicle was taken to an independent mechanic, where it was diagnosed that the transmission had unintendedly shifted from park(P) to reverse(R). The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 105,000. The VIN was not available.;
2000 LINCOLN CONTINENTAL Complaints
The contact owns a 1979 Lincoln Continental. The contact stated while the vehicle was parked and turned off, there was smoke coming from the vehicle. The contact stated that the rear end near the driver's side of the vehicle had caught on fire. The vehicle was extinguished by the Fire Department. A fire report was filed, and a fire report number was provided; however, the cause for the failure was not yet determined. A Police report was not filed. No injuries were sustained. The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was towed to an impound lot. The manufacturer was not made aware of the failure. The failure mileage was approximately 137,070. The VIN was invalid.;