VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES AND 8 FOOT BOXES

Nov 04, 1999 — Recall Campaign #99V311000

VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES AND 8 FOOT BOXES, MAY NOT FULLY SATISFY THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." IN A 30 MPH FRONTAL BARRIER CRASH TEST, A FUEL TANK VAPOR RECOVERY VALVE SEPARATED INTERNALLY. DURING THE SUBSEQUENT STATIC ROLLOVER TEST, FUEL SPILLAGE EXCEEDED THE SPECIFIED RATE.

The recall was influenced by the manufacturer with about 107,540 units affected.

See recall notice

NHTSA Safety Recall Notice

99V311000

Manufacturer:	Ford Motor Company
Recall date:	November 04, 1999
NHTSA Campaign #:	99V311000
Units affected:	107,540

Description:: VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH GASOLINE ENGINES AND 8 FOOT BOXES, MAY NOT FULLY SATISFY THE REQUIREMENTS OF FMVSS NO. 301, "FUEL SYSTEM INTEGRITY." IN A 30 MPH FRONTAL BARRIER CRASH TEST, A FUEL TANK VAPOR RECOVERY VALVE SEPARATED INTERNALLY. DURING THE SUBSEQUENT STATIC ROLLOVER TEST, FUEL SPILLAGE EXCEEDED THE SPECIFIED RATE.
Consequeces:: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective action:: DEALERS WILL INSTALL A STOP PLATE ASSEMBLY ON THE VEHICLE FRAME TO PREVENT RECOVERY VALVE CONTACT WITH A FRAME CROSSMEMBER DURING THE IMPACT SEQUENCE.
Notes:: FORD RECALL NO. 99S32.OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING NOVEMBER/DECEMBER 1999.OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-888-DASH-2-DOT (1-888-327-4236).

Affects the following:

2000 FORD F-250 Complaints
Odometer Fraud. The contact purchased a 1999 N/A Ford F-250. The contact discovered a mileage discrepancy after the purchase. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 176,369. The contact stated that the odometer was inoperable. The contact stated that the odometer only operated while the 4WD feature was activated. Upon further investigation, the contact became aware that when the previous owner purchased the vehicle in 2023, the mileage was 167,697. The correct odometer reading was unknown.;
2000 FORD F-350 Complaints
On [XXX], I rented a Class C motorhome from Cruise America at their Duluth, Georgia branch (Reservation #[XXX]). When I picked up the vehicle, the Cruise America employee pointed to a handwritten note taped over the tire pressure warning light on the dashboard that said: “ignore tire sensor.” The note was already in place before I arrived, suggesting that other renters may have used the vehicle in that same unsafe condition. Three days later, while traveling northbound on [XXX] near Memphis, Tennessee, the RV suffered a sudden tire blowout at highway speed. We narrowly avoided a collision while maneuvering to the shoulder. Thankfully, no one was injured, but the incident was extremely dangerous and could easily have resulted in fatalities. Cruise America knowingly rented out a vehicle with an active tire pressure warning covered and concealed, depriving the driver of critical safety information. The company did not repair or document the issue, instead instructing renters to “ignore” the tire warning. This conduct may violate Federal Motor Vehicle Safety Standard No. 138 (49 C.F.R. § 571.138) and 49 U.S.C. § 30122, which prohibit making safety equipment inoperative or misleading drivers about safety system status. While TPMS sensors can fail naturally, covering the warning light constitutes deliberate concealment and undermines the system’s purpose. I am concerned that Cruise America may be circulating other rental vehicles in similar unsafe condition. Please investigate whether Cruise America, Inc. is in compliance with federal vehicle-safety laws governing TPMS functionality and rental-vehicle maintenance standards. Specifically, whether any branch locations are renting vehicles with disabled, covered, or ignored tire-pressure monitoring systems or other concealed safety warnings. Reported to Cruise America Customer Relations (Case #[XXX]). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6);