BLUE BIRD WANDERLODGE Recalls

Nov 05, 2002 – CERTAIN MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM WITH SERIAL NUMBERS BETWEEN 700000 AND 1008700 AND MANUFACTURED BETWEEN DECEMBER 1996 AND FEBRUARY 1999. THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.

Jun 13, 2002 – ON CERTAIN MOTOR HOMES AND TOUR COACHES, A 'CHECK TRANS' WARNING LIGHT WHICH IS REQUIRED BY ALLISON TRANSMISSION INSTALLATION INSTRUCTIONS WAS OMITTED. IN THE EVENT THE TRANSMISSION SHIFT SELECTOR MALFUNCTIONS (LOOSES POWER OR SENDS ERRONEOUS SIGNALS TO THE TRANSMISSION ELECTRONIC CONTROL UNIT), THE COMPUTER WILL STOP ACCEPTING INPUT FROM THE ELECTRONIC SHIFT SELECTOR UNIT. IF THIS CONDITION OCCURS, THE TRANSMISSION WILL BE HELD IN THE LAST VALID RANGE SELECTED. ALTHOUGH THE SINGLE DIGIT RANGE SELECTED DISPLAY ON THE SHIFT SELECTOR WILL BE BLANK OR A DASH, THE DRIVER MAY NOT BE AWARE THAT A MALFUNCTION HAS OCCURRED.

Mar 21, 2002 – ON CERTAIN MOTOR COACHES/MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.

Feb 23, 2001 – VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES AND MOTOR HOME CHASSIS EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.

May 05, 2000 – VEHICLE DESCRIPTION: MOTOR HOME COACHES. THE TRAILER HITCH MAY BE INADEQUATELY WELDED TO THE CHASSIS FRAME.

Nov 01, 1999 – VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH CARBON MONOXIDE ALARMS. SOME OF THESE ALARMS MAY HAVE BECOME CONTAMINATED DURING SHIPPING WHICH WILL DIMINISH THE SENSITIVITY OF THE ALARM TO DETECT CARBON MONOXIDE.

Jun 29, 1999 – VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH RIDEWELL TAG AXLES. SOME OF THE RIDEWELL TAG AXLE AND SUSPENSION ASSEMBLIES HAVE THE BRAKE S-CAMS INCORRECTLY INSTALLED.

May 18, 1999 – VEHICLE DESCRIPTION: MOTOR HOME COACHES EQUIPPED WITH RIDEWELL FOLLOWING TAG AXLES. THE RIDEWELL FOLLOWING TAG AXLE LOCKING CYLINDERS CAN ALLOW THE TAG AXLE TO OFF-STEER, CAUSING A REAR END OVERSTEER PROBLEM.

May 17, 1999 – VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH RIDEWELL TAG AXLES. THE RIDEWELL TAG AXLE CASTER CONTROL ARM BOLTS CAN BACK OUT OF THE NUT SECURING IT, ALLOWING THE TAG AXLE TO MOVE OUT OF ALIGNMENT.

Jul 22, 1998 – VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH AQUA-HOT HEATING SYSTEMS, MODEL 431-3 ZONE WITH ENGINE LOOP. FIBERGLASS INSULATING MATERIAL LOCATED UNDER THE BURNER HEAD ON THE FLOOR OF THE HEATER ENCLOSURE, CAN BECOME SOAKED WITH FLUIDS (ETHYLENE GLYCOL AND/OR DIESEL FUEL).