BLUE BIRD Recalls

Apr 23, 2010 – BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 VISION SCHOOL BUSES MANUFACTURED FROM JANUARY 30, 2003 THROUGH SEPTEMBER 24, 2008. THE POWER CABLES RUNNING TO THE POWER DISTRIBUTION UNIT STUD AND DRIVER'S CONTROL MODULE STUD MAY HAVE BEEN INSTALLED WITH THE LUG (EYELET) FLAT SIDE UP. WHEN THIS CONDITION EXISTS, VIBRATION MAY WEAR THE INSULATION PERMITTING DIRECT CONTACT BETWEEN THE BARE LUG AND THE PDU OR DCM WHICH COULD CAUSE A DIRECT SHORT IN THE ELECTRICAL SYSTEM.

Apr 23, 2010 – BLUE BIRD IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2009 VISION NON-SCHOOL BUSES MANUFACTURED FROM SEPTEMBER 19, 2003 THROUGH JULY 2, 2008. THE POWER CABLES RUNNING TO THE POWER DISTRIBUTION UNIT STUD AND DRIVER'S CONTROL MODULE STUD MAY HAVE BEEN INSTALLED WITH THE LUG (EYELET) FLAT SIDE UP. WHEN THIS CONDITION EXISTS, VIBRATION MAY WEAR THE INSULATION PERMITTING DIRECT CONTACT BETWEEN THE BARE LUG AND THE PDU OR DCM WHICH COULD CAUSE A DIRECT SHORT IN THE ELECTRICAL SYSTEM.

Apr 05, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2011 ALL AMERICAN, CONVENTIONAL, AND MICRO BIRD SCHOOL BUSES MANUFACTURED FROM DECEMBER 13, 2007 THROUGH JANUARY 18, 2010 EQUIPPED WITH RICON MODEL S OR K SERIES PUBLIC USE WHEELCHAIR LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Apr 05, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2008 THROUGH 2010 ALL AMERICAN, CONVENTIONAL, AND MICRO BIRD TRANSI BUSES MANUFACTURED FROM DECEMBER 16, 2007 THROUGH DECEMBER 21, 2009 EQUIPPED WITH RICON MODEL S OR K SERIES PUBLIC USE WHEELCHAIR LIFTS. THE RESTRAINT BELT ON THESE LIFTS WAS DESIGNED TO PREVENT THE LIFT FROM MOVING, UNLESS THE TONGUE OF THE BELT IS FULLY ENGAGED AND LATCHED IN THE BUCKLE. RICON HAS DISCOVERED, HOWEVER, THAT IT IS POSSIBLE FOR THE OPERATOR TO INSERT THE BELT TONGUE INTO THE BUCKLE WITHOUT FULLY ENGAGING THE LATCHING MECHANISM. IN THIS CASE, THE RESTRAINT BELT WOULD APPEAR TO BE LATCHED, AND THE OPERATOR COULD RUN THE LIFT. IF THE RESTRAINT BELT TONGUE IS NOT FULLY ENGAGED INTO THE RESTRAINT BELT BUCKLE, AND LATCHED, THE LIFT MAY OPERATE WITH AN OCCUPANT ON THE PLATFORM.

Apr 05, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 ALL AMERICAN, CONVENTIONAL, AND MICRO BIRD SCHOOL BUSES MANUFACTURED FROM APRIL 24 THROUGH NOVEMBER 14, 2009 EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. THERE IS A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Apr 05, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 ALL AMERICAN TRANSIT BUSES MANUFACTURED FROM SEPTEMBER 23 THROUGH NOVEMBER 19, 2009 EQUIPPED WITH CERTAIN RICON S SERIES AND K SERIES L-MODEL WHEELCHAIR LIFTS. THERE IS A PROBLEM IN THE SOFTWARE THAT CONTROLS THE LIFT'S "UP" FUNCTION. IF THE "UP" SWITCH IS RELEASED BEFORE THE FLOOR LEVEL LIMIT SWITCH IS ACTIVATED, THE LIFT MAY CONTINUE ITS UPWARD TRAVEL FOR APPROXIMATELY 1 SECOND BEFORE STOPPING. THE CONTINUED UPWARD TRAVEL MAY OVERRUN THE FLOOR LEVEL CUT OFF POINT.

Mar 16, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 ALL AMERICAN SCHOOL BUSES MANUFACTURED FROM MAY 13, 2009 THROUGH FEBRUARY 26, 2010. THE WIRING HARNESS FOR THE REAR TAG LIGHT MAY BE OF INSUFFICIENT LENGTH RESULTING IN THE HARNESS BEING ROUTED IMPROPERLY AND EXPOSING THE CONNECTOR TO THE ENVIRONMENT WHICH COULD CAUSE THE CONNECTOR TO CORRODE. CORROSION COULD CAUSE A DIRECT SHORT IN THE TAG LIGHT CIRCUIT. A SHORT IN THE TAG LIGHT WIRING CIRCUIT, WHICH INCLUDES THE HEADLIGHT LOW BEAM CIRCUIT, COULD CAUSE SUDDEN LOSS OF HEADLIGHT LOW BEAMS.

Mar 02, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A NONCOMPLIANCE IN CERTAIN MODEL YEAR 2010 ALL AMERICAN REAR ENGINE SCHOOL BUSES MANUFACTURED FROM AUGUST 27, 2009 THROUGH JANUARY 25, 2010. ADHESIVE REQUIRED FOR INTERIOR REAR BULKHEAD PANELS WAS OMITTED. THE BUSES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, "SCHOOL BUS BODY JOINT STRENGTH."

Feb 05, 2010 – BLUE BIRD HAS NOTIFIED NHTSA ABOUT A DEFECT IN CERTAIN MODEL YEAR 2010 ALL AMERICAN REAR ENGINE SCHOOL BUSES MANUFACTURED BETWEEN JANUARY 5, 2009 AND JANUARY 18, 2010. THE BATTERY CABLES MAY HAVE BEEN IMPROPERLY ROUTED AT THE FRONT BOTTOM OF THE LARGE BATTERY COMPARTMENT RESULTING IN THE BATTERY CABLES POTENTIALLY BEING PINCHED BETWEEN THE FRONT BOTTOM OF THE BATTERY COMPARTMENT BOX AND THE EXHAUST MOUNTING BRACKET.

Dec 29, 2009 – NORTH AMERICAN BUS INDUSTRIES, INC. (NABI) IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2009 TRANSIT BUSES MANUFACTURED BETWEEN JANUARY 1, 2002, AND SEPTEMBER 15, 2009, AND EQUIPPED WITH LUMINATOR HORIZON LED SIDE DESTINATION SIGNS. THE CONNECTOR BOARD CAN CORRODE DUE TO AN ACCUMULATION OF MOISTURE UNDER THE CONNECTOR.