BLUE BIRD Recalls

Aug 30, 2007 – CERTAIN BLUE BIRD CONVENTIONAL SCHOOL BUSES BUILT WITH AN OPTIONAL FIREWALL HEATER HOSE CONNECTOR ON THE DRIVER'S SIDE OF THE BUS AND MANUFACTURED FROM NOVEMBER 21, 1985, THROUGH SEPTEMBER 14, 1993.

Aug 03, 2007 – CERTAIN BLUE BIRD MY 2008 ALL AMERICAN AND VISION SCHOOL BUSES MANUFACTURED BETWEEN JUNE 6 AND JULY 27, 2007. A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND CAUSE LOSS OF THROTTLE CONTROL AND EXCESSIVE SMOKE.

Jul 03, 2007 – CERTAIN MY 2006 THROUGH 2008 BLUE BIRD ALL AMERICAN REAR ENGINE SCHOOL AND TRANSIT BUSES MANUFACTURED FROM JANUARY 14, 2005, THROUGH MARCH 13, 2007, EQUIPPED WITH EMERGENCY PUSH OUT WINDOWS. THE SUBJECT BUSES WERE MANUFACTURED WITH INCORRECT NUMBER OF EMERGENCY EXITS WHICH DOES NOT COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.

Jun 26, 2007 – CERTAIN MY 2007 AND 2008 BLUE BIRD VISION AND ALL AMERICAN SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN DECEMBER 1, 2005, AND MAY 24, 2007, AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES. THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.

Jun 22, 2007 – CERTAIN BLUE BIRD MY 2004 THROUGH 2007 VISION SCHOOL AND TRANSIT BUSES MANUFACTURED BETWEEN OCTOBER 9, 2003, AND SEPTEMBER 21, 2006, EQUIPPED WITH PARKER SINGLE CHECK VAVLES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.

Feb 08, 2007 – CERTAIN BLUE BIRD 2007 AND 2008 VISION SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 9 AND OCTOBER 27, 2006. THE LIFT INNER BARRIER INTERLOCK SWITCH SYSTEM MAY NOT DETECT THE PRESENCE OF A PASSENGER ON THE INNER BARRIER AND ALLOW THE PLATFORM TO MOVE DOWN MORE THAN ONE INCH BELOW FLOOR LEVEL WHILE OCCUPIED WHICH DOES NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES.

Jan 29, 2007 – CERTAIN 2007 AND 2008 MY BLUE BIRD VISION SCHOOL BUSES MANUFACTURED BETWEEN OCTOBER 16, 2006, AND JANUARY 18, 2007. CONTINUOUS RESETTING OF THE CIRCUIT BREAKER WHEN THE WIPER/WASHER IS OPERATING IN THE WASH/WIPE MODE MAY CAUSE FAILURE IN THE WIRING CIRCUIT RESULTING IN POWER BEING APPLIED TO THE GROUND WHICH COULD CAUSE THE CIRCUIT BREAKER TO OVERHEAT AND FAIL RESULTING IN A STALLED WIPER.

Dec 06, 2006 – CERTAIN 2008 BLUE BIRD VISION SCHOOL BUSES BUILT FROM OCTOBER 23 THROUGH NOVEMBER 21, 2006. A TEMPORARY BOLT WAS USED TO SECURE THE STEERING WHEEL DURING THE MANUFACTURING PROCESS. THE TEMPORARY BOLT WAS TO BE REMOVED AND REPLACED WITH A PERMANENT BOLT WITH A LOCK COATING DURING THE FINAL ASSEMBLY STAGE. THE TEMPORARY BOLT WAS NOT REMOVED AND REPLACED ON THE SUBJECT UNITS, BUT INSTEAD THE BOLT WAS REUSED.

Sep 13, 2006 – CERTAIN MY 2007 BLUE BIRD VISION SCHOOL BUSES EQUIPPED WITH AIR BRAKES MANUFACTURED FROM AUGUST 17 THROUGH SEPTEMBER 5, 2006. AN INCORRECT FITTING WAS DESIGNED INTO THE SUBASSEMBLY FOR THE REAR AXLE BRAKE VALVE MODULE. A STANDARD 90 DEGREE ELBOW WAS USED WHERE A 90 DEGREE CHECK VALVE SHOULD HAVE BEEN USED. THESE BUSES FAIL TO CONFORM TO THE BLEED DOWN REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "BRAKE SYSTEMS.

Jul 26, 2006 – ON CERTAIN MOTOR HOMES AND TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES C-60 ENGINES, THE ELECTRONIC CONTROL MODULE (ECM) WILL REQUIRE TO BE REPROGRAMMED TO CURRENT MAINFRAME CALIBRATIONS.