BMW Recalls

Oct 12, 2007 – ON CERTAIN VEHICLES EQUIPPED WITH V8 ENGINES, IN CONDITIONS OF BELOW FREEZING TEMPERATURES COMBINED WITH LOW HUMIDITY, IT IS POSSIBLE FOR ELECTROSTATIC DISCHARGE TO OCCUR AT THE FUEL RAILS. IF THIS WERE TO OCCUR, THE ENGINE ELECTRONIC CONTROL UNIT (ECU) COULD BE AFFECTED SO THAT ENGINE STALLING COULD RESULT.

Oct 02, 2007 – ON CERTAIN MOTORCYCLES, DURING LONG PERIODS OF RIDING AT SUSTAINED HIGH ENGINE RPM, VIBRATION WITHIN THE BRAKE FLUID RESERVOIR CAN CAUSE THE BRAKE FLUID TO FOAM. THIS COULD ALLOW AIR TO ENTER THE FRONT BRAKE SYSTEM WHICH COULD LEAD TO A LOSS OF FRONT BRAKING EFFICIENCY.

Sep 06, 2007 – CERTAIN AFTERMARKET BMW BIKE CARRIERS, P/N 82110393954, SOLD FOR USE ON MY 2005 BMW X3 AND X5 VEHICLES. A PINCH BOLT EXISTS BETWEEN THE BIKE ARM BRACKET AND THE UPRIGHT ASSEMBLY OF THE HITCH STYLE BICYCLE RACK.

Aug 29, 2007 – CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, "PASSENGER CAR BRAKE SYSTEMS." THE CAP OF THE BRAKE FLUID RESERVOIR HAS BEEN DESIGNED IN ORDERTO RECOGNIZE A LOW FLUID LEVEL OF THE HYDRAULIC BRAKE SYSTEM BY TRIGGERING A RED WARNING LAMP IN THE INSTRUMENT CLUSTER. A SWITCH THAT IS ATTACHED TO THIS CAP COULD MALFUNCTION AT HIGH TEMPERATURES.

Aug 22, 2007 – ON CERTAIN MOTORCYCLES, THE FUEL PUMP WIRING SET HAS NOT BEEN MANUFACTURED ACCORDING TO SPECIFICATION. THE CONTACTS IN THE PLUG FOR THE FUEL PUMP CAN BREAK.

Aug 15, 2007 – ON CERTAIN MOTORCYCLES, A LEFT-SIDE CHAIN TENSIONER HAS BEEN INCORRECTLY INSTALLED ON THE RIGHT SIDE. AS A RESULT, A HEX NUT, WHICH IS USED TO SECURE THE CHAIN TENSIONER, IS IMPROPERLY SEATED AGAINST THE TENSIONER.

Aug 15, 2007 – ON CERTAIN MOTORCYCLES, THE CLAMPING BLOCKS AND THE TOP FORK BRIDGE WERE NOT MANUFACTURED ACCORDING TO SPECIFICATIONS. CONSEQUENTLY, THE HANDLEBARS MIGHT NOT BE HELD SECURELY IN POSITION.

Apr 25, 2007 – CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE FRONT PASSENGER SEAT HAS A SENSING SYSTEM TO DETECT IF THE SEAT IS OCCUPIED. THIS SENSING IS PROGRAMMED TO DETECT IF THE SEAT IS OCCUPIED BY A SMALL ADULT OR CERTAIN CHILD RESTRAINT SEATS. PLACING CERTAIN CHILD SEATS ON THE FRONT PASSENGER SEAT IS DESIGNED TO RESULT IN THE AUTOMATIC DEACTIVATION OF THE FRONT SEAT PASSENGER'S AIR BAG.

Apr 03, 2007 – ON CERTAIN MOTORCYCLES, THE WELD BETWEEN THE SIDE STAND AND THE FRAME BOTTOM SECTION WAS NOT POSITIONED PROPERLY. THE LOAD-BEARING CAPABILITY OF THE SIDE STAND IS AFFECTED. AS A RESULT, THE SIDE STAND COULD FAIL.

Mar 29, 2007 – CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.