COLLINS GRAND BANTAM Recalls

Sep 26, 2014 – Collins Bus Corporation (Collins) is recalling certain model year 2006-2014 Collins and Mid Bus Super Bantam, Grand Bantam, Super Guide, Grand Guide, DE416WR, DH416WR, and DE516WR school buses manufactured January 1, 2006, to June 16, 2014, and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.

Sep 25, 2013 – Collins Bus Corporation (Collins) is recalling certain model year 2009-2010 Bantam, Super Bantam, Grand Bantam, Mid Bus Guide, Super Guide, and Grand Guide school buses manufactured September 2009 through April 2010, and equipped with A&M Systems-brand electric door actuators. Voltage spikes may damage electrical components and electrical circuits, causing the circuit board to develop high resistance.

Jun 07, 2012 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2010 GRAND BANTAM, SUPER BANTAM, MID BUS GRAND GUIDE, AND MID BUS SUPER GUIDE SCHOOL BUSES MANUFACTURED FROM FEBRUARY 21, 2008, THROUGH SEPTEMBER 21, 2010, EQUIPPED WITH BRAUN CENTURY-2 WHEELCHAIR LIFTS. OVER TIME, AND WITH FREQUENT USE, THE ROLL STOP LATCHES ON THE OUTER BARRIER MAY BECOME BENT OR MISALIGNED.

Oct 14, 2011 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 BANTAM, GRAND BANTAM, AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM AUGUST 23, 2006, THROUGH FEBRUARY 1, 2008, EQUIPPED WITH CARRIER GENV EM-1 EVAPORATOR UNITS. DUE TO TIME, TEMPERATURE, AND/OR VIBRATION, THE FUSE MAY LOOSEN IN THE FUSE HOLDER RESULTING IN HIGH RESISTANCE AND ARCING.

May 23, 2011 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2002-2011 BANTAM, GRAND BANTAM, AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM OCTOBER 2002 THROUGH MAY 20, 2011, FOR FAILING TO CONFORM TO THE LEG PROTECTION ZONE IMPACT REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 222 "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Sep 28, 2010 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 SUPER BANTAM AND GRAND BANTAM AND MID BUS SUPER GUIDE AND GRAND GUIDE SCHOOL BUSES BUILT ON FORD AND CHEVROLET PLATFORMS FROM MARCH 31, 2008 THROUGH JULY 31, 2009, EQUIPPED WITH SPECIALTY MANUFACTURING, INC. (SMI) 000290 LED LIGHT KITS. A CHANGE TO THE WIRE USED IN THE LED LIGHT KITS MAY REDUCE THE EFFECTIVE LIFE OF THE LIGHTS USED ON THE STOP ARMS. THE LIGHTS MAY STOP FUNCTIONING WITHOUT WARNING.

Aug 02, 2010 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2008 BANTAM, GRAND BANTAM, AND SUPER BANTAM MODEL SCHOOL BUSES. THE 39 INCH THREE PASSENGER SEATS FAIL TO MEET THE MINIMUM PERFORMANCE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER AND CRASH PROTECTION."

Jun 29, 2010 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2010 GRAND BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED FROM OCTOBER 5, 2009 THROUGH JANUARY 4, 2010 AND BUILT WITH CERTAIN LAP SHOULDER BELT SEATS MANUFACTURED BY IMMI. THE SEAT CUSHION LOCKING MECHANISMS WERE MISALIGNED DURING VEHICLE ASSEMBLY. THIS FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, "SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION."

Feb 18, 2010 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2009 BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES MANUFACTURED BETWEEN APRIL 1 AND OCTOBER 1, 2009, BUILT ON FORD CUTAWAY CHASSIS. THE BRAKE-TURN SEPARATOR MODULE WHICH IS USED TO CONTROL THE BRAKE LIGHTS AND TURN SIGNALS LIGHTS IN THE REAR MAY NOT ALWAYS DISTINGUISH CORRECTLY BETWEEN A BRAKE SIGNAL INPUT AND A TURN SIGNAL INPUT FROM THE FORD CHASSIS OEM WIRING. FOR TYPICAL BRAKE AND TURN SIGNAL OPERATION, THE STOP/TAIL/TURN LIGHTS AT THE REAR OF THE BUS WILL FUNCTION PROPERLY. HOWEVER, IF THE BRAKES ARE PUMPED/APPLIED IN A FREQUENCY MATCHING THAT OF THE BLINKING TURN SIGNAL WHILE THE TURN INDICATOR IS ON, THERE IS THE POTENTIAL THAT THE BRAKE SIGNAL THROUGH THE MODULE MAY CANCEL OUT THE TURN SIGNAL TEMPORARILY OR CAUSE IT TO FLASH INTERMITTENTLY.

Dec 11, 2009 – COLLINS IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 GRAND BANTAM, SUPER BANTAM, MID BUS GRAND GUIDE, AND MID BUS SUPER GUIDE SCHOOL BUSES MANUFACTURED FROM FEBRUARY 14 TO OCTOBER 19, 2009, EQUIPPED WITH A BRAUN NCL917IB-2 CENTURY WHEELCHAIR LIFT. THE TOE STOP INNER BARRIER AND PLATFORM MAY NOT BE ADJUSTED CORRECTLY POSSIBLY ALLOWING THE UNIT TO BE MOVED TO THE STOW POSITION. THESE WHEELCHAIR LEFTS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES."