DAMON INTRUDER Recalls

Sep 09, 2010 – DAMON IS RECALLING CERTAIN MODEL YEAR 2007-2011 CHALLENGER, MODEL YEAR 2005-2007 INTRUDER MOTOR HOMES. THESE MOTOR HOMES DO NOT HAVE THE PROPER CLEARANCE BETWEEN THE REAR SUSPENSION LEAF SPRING AND THE VEHICLE LIQUID PROPANE FUEL TANK. AS THE SUSPENSION TRAVELS IT IS POSSIBLE FOR THE LEAF SPRING SHACKLE BOLT TO COME IN CONTACT WITH THE TANK. THIS POTENTIALLY COULD PUNCTURE THE TANK AND RESULT IN A FIRE OR EXPLOSION.

Jun 16, 2009 – DAMON IS RECALLING 2,415 MOTORHOMES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG.

Oct 09, 2008 – DAMON IS RECALLING 4,677 MY 2004-2006 CHALLENGER, DAYBREAK, INTRUDER, MY 2004-2005 ESCAPER, ULTRASPORT, AND MY 2005 ASTORIA AND ASTORIA WALDORF MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Jul 02, 2008 – DAMON IS RECALLING 804 MY 1999 INTRUDER, ULTRASPORT, AND ESCAPER MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

Jun 05, 2008 – DAMON IS RECALLING 265 MY 2007 INTRUDER (373, 374, 378), MY 2007-2009 OUTLAW (3611), AND MY 2009 CHALLENGER (371, 376, 377, 378) MOTOR HOMES BUILT ON FORD CHASSIS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE METRIC AND ENGLISH VALUES FOR THE TIRE AIR PRESSURES WERE INADVERTENTLY SWITCHED. THE LABELS READ 90KPA/620PSI AND SHOULD READ 620KPA/90PSI.

Mar 20, 2007 – CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.

Jan 30, 2007 – CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE BUILT WITHOUT THE RED REAR REFLEX REFLECTORS AND SOME MOTOR HOMES WERE BUILT WITHOUT THE SIDE REAR RED REFLEX REFLECTORS.

Nov 28, 2006 – ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.

Sep 12, 2006 – ON CERTAIN CLASS A MOTOR HOMES, SOME HYDRAULIC LINES FOR THE LEVELING JACK SYSTEM MAY BE IMPROPERLY SECURED OR ROUTED TOO CLOSE TO A DRIVE TRAIN HEAT SOURCE.

Jun 30, 2006 – CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.